Abstract:Our group proposed a diameter-varying spray tower and a new spray mode of dual-nozzle opposed impinging spray method to achieve the low-energy-consumption and environmentally-friendly CO2 capture process and some meaningful results have been obtained by experiments. However, the detailed information about the hydrodynamics (like liquid and gas phase distribution, gas-liquid contacting area and gas-liquid contacting time causing by impinging spray) inside the proposed tower is hard to be obtained by experimental work. In this work, to specifically explain the hydrodynamic mechanism with impinging spray inside the proposed spray tower, ANSYS Fluent18.0 and Euler-Lagrange approach were used to simulate the complex gas-liquid two-phase flow based on experimental results. The effects of nozzle location, nozzle number, spray angle, liquid injection velocity and gas intake mode were investigated, and the optimal design scheme of the spray tower was proposed. Simulation results indicated that the dual-nozzle opposed impinging spray method (DOSM) showed better absorption performance compared with the single-nozzle side spray method (SSSM) and single-nozzle middle spray method (SMSM). Spray angle of 60 degrees had efficient gas-liquid distribution. The liquid inlet velocity of 8 m?s? 1 was suggested under the experimental conditions. The double-sided gas intake mode intensified gas-liquid absorption performance. The simulation results were well verified by experiments. The relationship between flow field optimization and CO2 absorption performance enhancing was also discussed comprehensively. Finally, it was concluded that both the numerical simulation and experimental results proved that the diameter-varying spray tower with the impinging spray method is a promising reactor for the CO2 capture system.

Study on Effective Phase Interfacial Area at Different Injection Angles of Hydro-Jet Cyclone

Performance Evaluation of a New Micro Gas Cyclone Using Simulation and Experimental Studies to Capture Indoor Fine Particles

On the Effect of Axial Inlet Angle on the Droplet Size Distribution and Mixing Uniformity for Swirl Jet Mixer at High Phase Ratios

CFD investigation of flow hydrodynamics and optimization in an industrial‐scale annular lance with swirl flow

Cyclones of Different Sizes and Underflow Leakage for Aerosol Particles Separation Enhancement

Hydrodynamic Mechanism Study of the Diameter-Varying Spray Tower with Atomization Impinging Spray

Multi-objective optimization of axial-flow-type gas-particle cyclone separator using response surface methodology and computational fluid dynamics

Experimental Study of De-Foulant Hydrocyclone Performance with a Conical Surface

Numerical Simulation of a Novel Hydrocyclone Mixer Structurally Optimized for Mixing Performance and Energy Efficiency

Hydrodynamics and mass transfer characteristics in an internal loop airlift reactor with sieve plates

Experimental Investigation of Oil Film Flow and Droplets Behavior in the Annular Channel of a Cyclone Separator

Experimental investigation on separation characteristics of axial cyclone separator

Experimental and Numerical Investigation on the Separation of Hydrophilic Fine Particles Using Heterogeneous Condensation Preconditioning Technique in Gas Cyclones

AN EXPERIMENTAL STUDY ON THE GAS-SOLID TWO-PHASE FLOW IN A SQUARE CYCLONE SEPARATOR WITH DOWNWARD GAS EXIT BY 3D-PDA

Analysis of Performance of Novel Hydrocyclones in Ebullated Bed Reactor with Different Vortex Finder Structures

Impact of Liquid Crossflow on the Discharge Coefficient of a Gas Jet Hole on a Flat Plate

Effect of concave‐wall jets with circumferential multi‐inlet on liquid–solid separation

Design and performance study of a two-stage inline gas-liquid cyclone separator with large range of inlet gas volume fraction

Experimental study on the gas-solid two-phase flow in a square cyclone separator with downward gas exit by particle dynamic analyzer

Numerical Study on the Interaction of Geometric Parameters of a Transcritical CO2 Two-Phase Ejector Using Response Surface Methodology and Genetic Algorithm

Experimental Investigation of a Minihydrocyclone