Abstract:The concentration of carbon dioxide (CO2) in the atmosphere is progressively increasing due to industrial development, leading to environmental concerns such as the greenhouse effect. Consequently, it is crucial to decrease dependence on the fossil fuels and mitigate the CO2 emissions. Photothermocatalysis technology facilitates the conversion of light energy into heat energy on the surface of catalysts, thereby driving chemical reactions. This catalytic approach effectively harnesses ample solar energy, consequently reducing non-renewable energy consumption. Solar-driven CO2 methanation is an important route to simultaneously mitigate excessive carbon emissions and produce fuels. Layered double hydroxides (LDH) can be reduced at high temperature in a reductive atmosphere of a hydrogen/argon (H2/Ar) mixture to prepare metal-loaded oxide (MO) catalysts, which are widely used in CO2 hydrogenation reactions as excellent photothermal catalysts. However, there is limited study on how the interlayer anion type of LDH affects the activity of CO2 methanation. Herein, a series of LDH precursors, intercalated with various anions, were synthesized using a co-precipitation method. The LDH precursors were reduced in a H2/Ar atmosphere to acquire a group of nickel (Ni) loaded on alumina (Al2O3) catalysts, referred to as NiAl-x-MO (x = CO3, NO3, Cl, and SO4, which represents carbonate, nitrate, chloride, and sulfate anions, respectively). Energy dispersive spectrometer (EDS) elemental mapping and X-ray photoelectron spectroscopy (XPS) results revealed the presence of nitrogen (N), chlorine (Cl), and sulfur (S) species on the surfaces of NiAl-NO3-MO, NiAl-Cl-MO, and NiAl-SO4-MO catalysts, respectively. Photothermocatalytic tests were conducted on the catalysts to assess the potential influence of the residual species on CO2 methanation. Among them, the NiAl-CO3-MO catalyst demonstrated a CO2 conversion of 50.1%, methane (CH4) selectivity of 99.9%, along with a CH4 production rate of 94.4 mmol∙g−1∙h−1. The performance of the NiAl-NO3-MO catalyst was found to be comparable to that of the NiAl-CO3-MO catalyst. In contrast, the CO2 methanation activity of the NiAl-Cl-MO and NiAl-SO4-MO catalysts were negligible. CO2 temperature programmed desorption (CO2-TPD) analysis demonstrated that the presence of N, Cl, and S species had a negligible effect on the adsorption of CO2. H2 temperature programmed desorption (H2-TPD) and density functional theory (DFT) results suggested that the strong coordination bond between residual Cl or S species and metallic Ni impeded the absorption and activation of H2, which was responsible for the low CO2 conversion. Hence, the significant role of the interlayer anion in LDH should be preferentially considered when designing LDH-derived catalysts, especially the Ni-based catalysts for hydrogenation reactions.

Atomic Layer Deposition of Alumina on Hollow Nickel Phyllosilicate Nanosheets for Enhanced CO2 Thermal Hydrogenation Performance

Hydrogen Production from Partial Oxidation of Propane: Effect of SiC Addition on Ni/Al2O3 Catalyst

Hierarchical hollow Ni/γ-Al2O3 catalyst derived from flower-like Ni-Al layered double hydroxide with stable catalytic performance for CO2 methanation

Atomic Layer Deposition of Ni on Cu Nanoparticles for Methanol Synthesis from CO2 Hydrogenation

Monolithic Ni5Ga3/SiO2/Al2O3/Al-fiber Catalyst for CO2 Hydrogenation to Methanol at Ambient Pressure

Effect of Ni Content of Ni/-Al2O3 Catalysts Prepared by the Atomic Layer Deposition Method on CO2 Reforming of Methane

Atomic Layer Deposition (ALD) as a Way to Prepare New Mixed-Oxide Catalyst Supports: The Case of Alumina Addition to Silica-Supported Platinum for the Selective Hydrogenation of Cinnamaldehyde

Revealing the Anti-Sintering Phenomenon on Silica-Supported Nickel Catalysts During CO2 Hydrogenation

Ni‐Al2O3/Ni‐foam catalyst with enhanced heat transfer for hydrogenation of CO2 to methane

Simultaneously quantitative and qualitative regulation of active sites of Ni-phyllosilicate for enhanced CO 2 hydrogenation to methane

Ni<sub>12</sub>P<sub>5</sub> Confined in Mesoporous SiO<sub>2</sub> with Near-Unity CO Selectivity and Enhanced Catalytic Activity for CO<sub>2</sub> Hydrogenation

Simultaneously Quantitative and Qualitative Regulation of Active Sites of Ni-Phyllosilicate for Enhanced Co2 Hydrogenation to Methane

Sub-Monolayer Control of Mixed-Oxide Support Composition in Catalysts Via Atomic Layer Deposition: Selective Hydrogenation of Cinnamaldehyde Promoted by (Sio2-Ald)-pt/al2o3

Ni-based catalysts derived from layered-double-hydroxide nanosheets for efficient photothermal CO2 reduction under flow-type system

Promotion Effects of Nickel-Doped Al2O3-nanosheet-supported Au Catalysts for CO Oxidation

Development of Highly Stable Ni-Al 2 O 3 Catalysts for CO Methanation

Ni/MgO Al2O3 Catalyst Derived from Modified [Ni,mg,al]-Ldh with NaOH for CO2 Reforming of Methane

Ultrathin Atomic Layer Deposited Al2O3 Overcoat Stabilizes Al2O3-Pt/Ni-Foam Hydrogenation Catalysts

NiAlFe catalysts based on hydrotalcite-like precursors for low temperature CO 2 methanation: Electronic effects among components and intrinsic activity of Ni site

Effect of Interlayer Anions in Layered Double Hydroxides on the Photothermocatalytic CO2 Methanation of Derived Ni-Al2O3 Catalysts

Enhancing CO<sub>2</sub> Hydrogenation Using a Heterogeneous Bimetal NiAl-Deposited Metal-Organic Framework NU-1000: Insights from First-Principles Calculations