Abstract:A novel plasma-driven catalysis (PDC) reactor with special structure was proposed to remove vehicle exhaust gas. The PDC reactor which consisted of three quartz tubes and two copper electrodes was a coaxial dielectric barrier discharge (DBD) reactor. The inner and outer electrodes firmly surrounded the outer surface of the corresponding dielectric barrier layer in a spiral way, respectively. Nano-titanium dioxide (TiO2) film prepared by radiofrequency (RF) magnetron sputtering was coated on the outer wall of the middle quartz tube, separating the catalyst from the high voltage electrode. The spiral electrodes were designed to avoid overheating of microdischarges inside the PDC reactor. Continuous operation tests indicated that stable performance without deterioration of catalytic activity could last for more than 25 h. To verify the effectiveness of the PDC reactor, a non-thermal plasma(NTP) reactor was employed, which has the same structure as the PDC reactor but without the catalyst. The real vehicle exhaust gas was introduced into the PDC reactor and NTP reactor, respectively. After the treatment, compared with the result from NTP, the concentration of HC in the vehicle exhaust gas treated by PDC reactor reduced far more obviously while that of NO decreased only a little. Moreover, this result was explained through optical emission spectrum. The O emission lines can be observed between 870 nm and 960 nm for wavelength in PDC reactor. Together with previous studies, it could be hypothesized that O derived from catalytically O-3 destruction by catalyst might make a significant contribution to the much higher HC removal efficiency by PDC reactor. A series of complex chemical reactions caused by the multi-components mixture in real vehicle exhaust reduced NO removal efficiency. A controllable system with a real-time feedback module for the PDC reactor was proposed to further improve the ability of removing real vehicle exhaust gas.

Enhancement of Flue Gas Low-Concentration Toluene Removal in Pulsed Plasma Coupling with Porous Ceramic Modified Catalyst Reactor

Removal of Dilute VOCs in Air by Post-Plasma Catalysis over Ag-based Composite Oxide Catalysts

Plasma Induced Toluene Decomposition on Alumina-Supported Mn-Based Composite Oxides Catalysts

Toluene Decomposition by a Two-stage Hybrid Plasma Catalyst System in Dry Air

Non-thermal plasma coupled with CM/Z5 catalyst for toluene removal

VOCs degradation with non-thermal plasma and Ag-MnOx catalysis

Characteristics of Back Corona Discharge in a Honeycomb Catalyst and Its Application for Treatment of Volatile Organic Compounds.

Utilizing catalyst to enhance pulse discharge for volatile organic compounds treatment

Nonthermal plasma coupled with Mn/N-doped carbon catalysts for highly efficient removal of toluene

Low-temperature Catalytic Oxidation of PCDD/Fs over MnCeCoOx/PPS Catalytic Filter

Refluxing-coprecipitation to synthesize Fex−Mny/γ-Al2O3 catalyst for toluene removal in a nonthermal plasma-catalysis reactor

By-product reduction for the non-thermal plasma removal of toluene using an α-MnO 2 /Cordierite honeycomb monolithic catalyst in a honeycomb structure

Vehicle Exhaust Gas Clearance By Low Temperature Plasma-Driven Nano-Titanium Dioxide Film Prepared By Radiofrequency Magnetron Sputtering

Plasma-catalytic oxidation of toluene over MCeZrO x /TiO 2 (M = Cu, Mn, Ni and Co) catalysts using a dielectric barrier discharge reactor

Highly Efficient Decomposition of Toluene Using a High-Temperature Plasma-Catalysis Reactor.

Scale-up Experiment of Plasma Reactors with Different Electrode Structure

Enhanced removal of toluene by pulse discharge plasma coupled with MgO cathode and graphene Mn–Ce bimetallic oxide

Oxidation of Organic Compounds in Cooking Fumes by Combining Nonthermal Plasma with Mn/HZSM-5 Catalysts

Cracking of toluene by corona plasma combined with MnO 2 /CeO 2 catalyst loaded on corona anode surface

Decomposition of Toluene Using Nanosecond- Pulsed-Discharge Plasma Assisted with Catalysts

Byproducts and pathways of toluene destruction via plasma-catalysis