Abstract:Non-thermal plasma (NTP) coupled with catalyst is a cutting-edge technique for the abatement of chlorinated volatile organic compounds (Cl-VOCs), which are typically chemically stable, highly toxic and non-biodegradable. In this study, different morphologies of 3D MnO 2 catalysts were fabricated facilely through a hydrothermal method and coupled with NTP for trichloroethylene (TCE) degradation. Among the various catalysts tested, MnO 2 IV exhibited the highest TCE degradation performance, with removal efficiency, mineralization and energy yield ranging from 44.3% to 94.8%, 28.9% to 90.1% and 5.76 to 2.31 g/kWh, respectively, at voltage levels between 7 and 11 kV. The relationship between the physicochemical properties of the catalysts and their degradation performance was established through various characterization methods. The exceptional catalytic efficiency of MnO 2 IV can be ascribed to its hierarchical flower-like structure, the greatest specific surface area (120 m 2 /g), the weakest Mn-O bonds, increased lattice defects and oxygen vacancies, and lower H 2 reduction temperature. These characteristics facilitate enhanced transfer, adsorption, and utilization of reactive oxygen species in NTP on the surface of MnO 2 IV, promoting the deep oxidation of TCE. The optimization of operational parameters was achieved using response surface methodology, with results indicating that the applied voltage exerted the greatest influence on both the mineralization rate and energy yield. The optimal operating conditions were determined, with initial TCE concentration, applied voltage, and gas flow rate values identified as 393 ppm, 7.3 kV, and 0.83 L/min, respectively. Lastly, the TCE degradation mechanism in the NTP-MnO 2 catalyst system was hypothesized based on the identification of various plasma reactive species and organic intermediates. This study provides new insights for the improvement of the VOCs oxidation performance in plasma catalytic system.

Plasma Induced Toluene Decomposition on Alumina-Supported Mn-Based Composite Oxides Catalysts

Toluene Decomposition by a Two-stage Hybrid Plasma Catalyst System in Dry Air

Removal of Dilute VOCs in Air by Post-Plasma Catalysis over Ag-based Composite Oxide Catalysts

VOCs degradation with non-thermal plasma and Ag-MnOx catalysis

In-plasma Catalytic Degradation of Toluene over Different MnO 2 Polymorphs and Study of Reaction Mechanism

Non-thermal Plasma Generation by Using Back Corona Discharge on Catalyst

Nonthermal plasma coupled with Mn/N-doped carbon catalysts for highly efficient removal of toluene

Decomposition of Toluene Using Nanosecond- Pulsed-Discharge Plasma Assisted with Catalysts

The Roles of Various Plasma Active Species in Toluene Degradation by Non-thermal Plasma and Plasma Catalysis

By-product reduction for the non-thermal plasma removal of toluene using an α-MnO 2 /Cordierite honeycomb monolithic catalyst in a honeycomb structure

Toluene Decomposition by Non-Thermal Plasma Assisted 2d Coox/Al2o3: the Relative Contributions of Specific Energy Density of Plasma, Co 3+ and Oxygen Vacancy

Plasma-catalytic oxidation of toluene over MCeZrO x /TiO 2 (M = Cu, Mn, Ni and Co) catalysts using a dielectric barrier discharge reactor

Cracking of toluene by corona plasma combined with MnO 2 /CeO 2 catalyst loaded on corona anode surface

Facile fabrication of three-dimensional MnO 2 for trichloroethylene degradation by plasma catalysis

Effect of Supports on Plasma Catalytic Decomposition of Toluene Using in Situ Plasma DRIFTS.

Toluene decomposition by DBD-type plasma combined with metal oxide catalysts supported on ferroelectric materials

Plasma-catalytic Removal of Toluene over the Supported Manganese Oxides in DBD Reactor: Effect of the Structure of Zeolites Support.

Performance and mechanism analysis of degradation of toluene by DBD plasma-catalytic method with MnOx/Al2O3 catalyst

Material extrusion additively manufactured alumina monolithic structures to improve the efficiency of plasma-catalytic oxidation of toluene

Refluxing-coprecipitation to synthesize Fex−Mny/γ-Al2O3 catalyst for toluene removal in a nonthermal plasma-catalysis reactor

Non-thermal Plasma Catalysis for Chlorobenzene Removal over CoMn/TiO2 and CeMn/TiO2: Synergistic Effect of Chemical Catalysis and Dielectric Constant