Abstract:Numerical simulations were conducted to study the effects of the pulverized-coal bias distribution in the primary air on the coal combustion and NOx generation characteristics of a 600-MW down-fired boiler with multiple-injection and multiple-staging combustion technology. The total pulverized-coal in the primary air was kept constant, and the ratio of the pulverized-coal mass flux in the fuel-rich coal/air flow to the total pulverized-coal mass flux (RPR) was set as 60%, 70%, 80%, and 90%. By changing the RPR, the excess air coefficient of the fuel-rich flow was adjusted from 0.700 to 0.467. It was found that numerical simulation results were almost in agreement with cold modeling and in situ experimental results respectively, including the flow fields in the lower furnace at the RPR of 80% and the heating processes for the fuel-rich coal/air flow at the RPR of 90%, which verified the rationality of the numerical model and the grid. The simulation results indicated that the change of RPR has little effect on the symmetry of the flow field in the furnace. With the increase of the RPR from 60 to 90%: (1) the maximum airflow declination angle near the tertiary air slot decreased from 71 to 66°, which indicates that the downward airflow penetration depth gradually decreased; (2) the ignition distance of the fuel-rich coal/air flow decreased from 1.2 to 0.9 m, and the high-temperature area in the furnace hopper decreased and the position gradually moved away from the hopper water walls; (3) the oxygen consumption rate at the initial combustion stage constantly accelerated, and the fuel NOx generation rate under the fuel-rich flow nozzle increased first and then decreased; (4) the NOx emissions at the furnace exit dropped from 778 to 662 mg/m3 at 6% O2, and the carbon in the fly ash decreased from 5.87 to 5.52%. Increasing the RPR reasonably controlled the excess air coefficient of the fuel-rich flow, and realized the high-efficiency combustion in the furnace and the reduction of NOx emissions simultaneously.

Influence of air ratio on combustion and NO<i><sub>x</sub></i> emission characteristics of pulverized coal industrial boiler

STUDY ON ELIMINATING FIRE-CARRYING IN PRIMARY AIR JET ORIFICE BY ADMIXING EXHAUST GAS

Numerical simulation investigations into the influence of the mass ratio of pulverized-coal in fuel-rich flow to that in fuel-lean flow on the combustion and NOx generation characteristics of a 600-MW down-fired boiler

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Influence of improving medium-speed pulverizer outlet temperature on the operation of boiler

Industrial experimental study on combustion characteristics and NOx emission characteristics of a 600 MWe wall‐fired boiler under ultra‐low excess air coefficient conditions

Tertiary air operation optimization aiming at low NOx combustion in boiler

Low NO_x Combustion Tests on a 200MW Coal-Water Slurry Fired Boiler

Tertiary Air Operation Optimization Aiming at Low NO_x Combustion in Boiler

Numerical study on the effects of primary air ratio on ultra-low-load combustion characteristics of a 1050 MW coal-fired boiler considering high-temperature corrosion

Combustion Performance and NO Emission in Industrial Furnace under Preheated Air Condition with Different Excess Air Ratio

Experimental research on the fire-carrying problems in primary air nozzle of 125 MW units

Analysis of the Mixing Between Primary Air and Secondary Air in a Low NOx Swirl Burner

Influence of Separated Overfire Air Ratio and Location on Combustion and NOx Emission Characteristics for a 600 MWe Down-Fired Utility Boiler with a Novel Combustion System

CONCENTRATED PRIMARY AIR ARRANGEMENT TO MAKE BITUMINITE BURNED BOILER SLAGGING - PREVENT AND LOW NOx RELEASE

ICOPE-15-C078 Effects of Vent Air Angles on Combustion and NO Emission Characteristics for a Down-Fired 600MW Pulverized-Coal Utility Boiler Retrofitted with a Novel Combustion System

Influence of Stoichiometric Ratio at Initial Combustion Stage onNOx Formation and Emission Characteristics of a Utility Boiler

Industrial Experiment on NO x Reduction by Urea Solution Injection in the Fuel-Rich Zone of a 330 MW Tangentially Pulverized Coal-Fired Boiler

CHARACTERISTICS OF NOX EMISSION AND REMOVAL FOR COAL FIRED UTILITY BOILER

Measurements of Swirling Coal Combustion and NO Formation

Influence of Secondary Air Ratio on Gas-Solid Mixing and Combustion in a 300mwe CFB Boiler Furnace