Abstract:Grate furnaces are essentially equipped with the partitioned primary air and secondary air for regulating low-NO x combustion. However, habitual operations with primary air distributing uniformly on the grate and secondary air opened, present high NO x emissions and low burnout. While a comprehensive investigation into the in-furnace flow, coal combustion, and NO x formation (used to first explain and then improve these problems) is absent up to now. Accordingly, within a 75 t/h coal-fired reversal grate furnace, both full-scale tests and simulations were performed first at its habitual operation case. Subsequently, with secondary air completely shut off, four primary-air distribution forms of the uniform air (UA), front-lean air (FLA), middle-concentrated air (MCA), and rear-enhanced air (REA) were evaluated to compare the horizontal primary-air staging conditions. Flow-field deflection and asymmetric combustion occurred, with the upward gas deflecting toward the rear-wall side and the front-half furnace dominated by a weak recirculation zone without effective combustion. Using the UA but closing secondary air not only dropped effectively NO x but also improved a little burnout. This performance ruled against the vertical air-staging function of secondary air. In the order of UA, FLA, MCA, and REA to deepen the horizontal primary-air staging, the flow-field deflection and asymmetric combustion generally deteriorated a little. The in-furnace combustion first strengthened and then weakened. NO x emissions descended continuously. Among the four cases, the MCA attained the optimal low-NO x combustion performance (i.e. NO x emissions of 267 mg/m 3 at 6% O 2 and burnout loss of 6.14%, respectively). In comparison to the corresponding levels of 486 mg/m 3 and 5.4% at the habitual case, this simple MCA staging setup without any combustion modification, dropped NO x emissions by approximately 45% while raised only a little burnout loss.

STUDY ON ELIMINATING FIRE-CARRYING IN PRIMARY AIR JET ORIFICE BY ADMIXING EXHAUST GAS

Solution to the Problems of Fire-Carrying in Primary Air Jet Orifice in 125MW Units

Experimental research on the fire-carrying problems in primary air nozzle of 125 MW units

CONCENTRATED PRIMARY AIR ARRANGEMENT TO MAKE BITUMINITE BURNED BOILER SLAGGING - PREVENT AND LOW NOx RELEASE

EXPERIMENTAL STUDY ON THE PROPERTY OF Nox EMISSION IN HIGH TEMPERATURE COMBUSTION OF COMMONLY USED COAL SORTS AND THEIR MIXTURES IN LARGE-SCALE TANGENTIALLY FIRING PULVERIZED COAL BOILERS

Research Of Low Nox Combustion With Large-Angle Counter Flow Of A Fuel-Rich Jet And Its Particle-Dynamics Anemometer (Pda) Experiment

Study and Actualization of Burning Bituminous Coal in Lean Coal-fired Boiler of the 300 MW Unit

Applied Study of Low Concentration Combustible Waste Gases Serving as an Auxiliary Fuel in a Coal-fired Boiler

TEST STUDY ON INFLUENCE OF AIR-DISTRIBUTING MODE FOR BURNERS UPON LOW EMISSION OF Nox

Mixing Firing of Blast Furnace Gas in a 200 MW Coal-Fired Utility Boiler

A New Integrated Secondary Air Device for Smoke Prevention and Dust Control

Experimental study and numerical simulation on the gas-solid two-phase flow field in the furnace of a 300MW tangentially fired utility boiler

Feasibility Study on the Reburning with Fine Coal Particles Based on Tertiary Air Retrofit in Pulverized Coal Fired Boilers

Technical Reform Of 75t/H Pulverized Coal And Blast Fuenace Gas (Bfg) Combustion Boiler

The Experimental Research on Combustion Character and Air Distribution in Stoker Firing High Volatile Coal

Partitioning Primary Air to Strengthen Efficiently the Horizontal Air-Staging Conditions within a 75 T/H Coal-Fired Reversal Grate Furnace

RESEARCH AND ENGINEERING APPLICATION ON SOLVING SLAGGING PROBLEM OF HEXAGONAL TANGENTIALLY FIRED BOILER

Experimental Study of a Dual Channel Bias and Exhaust Gas OFA Combined Pulverized Coal Burner

Airflow And Combustion Characteristics And Nox Formation Of The Low-Volatile Coal-Fired Utility Boiler At Different Loads

A novel coal combustion technology for a down-fired boiler: Aerodynamic characteristics

Experimental Study on Nox Emission and Unburnt Carbon of A Radial Biased Swirl Burner for Coal Combustion