Abstract:Small-scale laboratory experiments of airflow through a single burner model and industrial-scale experiments on the centrally fuel-rich, low NOx swirl burner on a 300-MW wall-fired subcritical boiler burning low-volatile coal under deep air staging were performed. The aerodynamic characteristics, flue gas temperature, and gas concentrations were measured for various vane angles of outer secondary air in the burner nozzle region. The results show that a stable, symmetric central reverse-flow zone forms close to the exit of the burner nozzle region under deep air staging. With decreasing vane angle, i) the maximum axial, radial, and tangential velocities and swirl intensity of the airstream increase; ii) the decaying rate of velocity increases between X/D = 0 and X/D = 0.8; iii) the maximum diameter, length, and the jet divergence angle of the central reverse-flow zone increase; and iv) the relative reverse-flow rate increases. While the primary air concentration decreases slightly, the maximum primary air concentration decreases rapidly with decreasing vane angle. In contrast, the maximum axial relative mixing rate increases in the initial stage along the airstream direction. A decrease in vane angle increases the flue gas temperature, the rate of increase indicating a closer ignition position of the anthracite and lean coal along the airstream direction of the burner. The O-2 consumption rate and NOx formation rate increase in the initial stage of combustion, whereas in the later stage the CO concentration increases notably and the O-2 concentration remains almost constant below 1%. The CO concentration can exceed 20,000 ppm, which restrains the NOx formation and reduces the NOx concentration notably, but beyond X' = 0.8 m, the NOx concentration remains almost constant. The flue gas temperature varies slightly for different vane angles in the side-wall region. The O-2 concentration exceeds 4% near the location of the water-cooled wall. The O-2 concentrations are below 2% and the CO concentrations are above 5000 ppm along the radial direction 1.8375 m <= R' <= 2.3375 m from the centerline of the burner in the side-wall region. With decreasing vane angle, the CO concentration increases while the NOx concentration decreases. (C) 2016 Energy Institute. Published by Elsevier Ltd. All rights reserved.

Measurements of Swirling Coal Combustion and NO Formation

Effect of Outer Secondary Air on Swirling Pulverized-Coal Combustion and NO Formation

The Effect of the Mixing Characters of Primary and Secondary Air on NOx Formation in a Swirling Pulverized Coal Flame

Influence of Primary Air Ratio on Flow and Combustion Characteristics and NOx Emissions of a New Swirl Coal Burner

Studies of the Effect of a Coal Concentrator on NO Formation in Swirling Coal Combustion

Effect of Secondary Air Mass Flow Rate on the Airflow and Combustion Characteristics and NOx Formation of the Low-Volatile Coal-Fired Swirl Burner

Effect of secondary air mass flow rate on the airflow and combustion characteristics and NOx formation of the low‐volatile coal‐fired swirl burner

Measurement of Swirling Turbulent Combustion and NO_x Formation

Analysis of the Mixing Between Primary Air and Secondary Air in a Low NOx Swirl Burner

Experimental investigation into pulverized-coal combustion performance and NO formation using sub-stoichiometric ratios

Influence of Different Outer Secondary Air Vane Angles on Flow and Combustion Characteristics and Nox Emissions of A New Swirl Coal Burner

Effects of Particle Concentration Variation in the Primary Air Duct on Combustion Characteristics and NO X Emissions in a 0.5-MW Test Facility with Pulverized Coal Swirl Burners

Numerical Simulation of the Combustion Characteristics of a Low NOx Swirl Burner: Influence of the Primary Air Pipe

NOx FORMATION IN SWIRL COAL BURNER WITH PULVERIZED-COAL CONCENTRATOR

Gas/particle Flow and Combustion Characteristics and NO X Emissions of a New Swirl Coal Burner

Effect of Outer Secondary-Air Vane Angle on the Flow and Combustion Characteristics and Nox Formation of the Swirl Burner in A 300-Mw Low-Volatile Coal-Fired Boiler with Deep Air Staging

Effects of Swirl Number for the External Secondary Air on the Turbulent Combustion and NOx Formation in a Swirl Combustor

Effect of the Vane Angle for Outer Secondary Air on the Flow and Combustion Characteristics and NO X Emissions of the Low-NO X Axial-Swirl Coal Burner

Effects of Secondary Air on Flow, Combustion, and NOx Emission from a Novel Pulverized Coal Burner for Industrial Boilers

Effects of Staged Air Injection on Combustion Pollutant Formation in a Swirl Combustor

Numerical Investigation on Flow Characteristics and Emissions under Varying Swirler Vane Angle in a Lean Premixed Combustor