Abstract:The interface plays an important role in determining strength and toughness in multiphase systems and the accurate measurement of the interface structure in single crystal (SX) Ni-based superalloy is also essential. In this work, the γ and γ' lattice constant, γ/γ' interface width at dendritic and interdendritic region of casting and solution treatment SX Ni-based superalloy is measured. Various advanced equipment is used to characterize γ/γ' interface nanostructure. A typical correlation between interface width and γ/γ' misfit is also summarized. The interface width in the dendritic region of the as-cast sample is larger than that in the interdendritic region. The misfit in the dendritic region is larger than that in the interdendritic region, which has a trend of negative development. There is a common law of the as-cast interdendritic and dendrite interface sample, where the absolute value of the misfit between the two phases is increasing with the phase interface broadening. The comparison of the as-cast and heat-treated interdendritic sample shows that after heat treatment, the phase interface width increases, the misfit decreases, the lattice constant of γ phase increases, and the lattice constant of the γ' phase decreases. By comparing the as-cast and heat treated dendrites, the absolute value of the misfit of the as-cast dendrite sample is significantly smaller than that of the heat-treated sample, and the misfit increases with the interface broadening. The comparison between interdendritic and dendritic heat-treated samples shows that the absolute value of the misfit between the two phases is smaller than that of the dendritic as-cast samples, and the absolute value of the misfit also increases with the phase interface broadening. In conclusion, property heat treatment can significantly increase the lattice constants of the γ and γ' phases, reduce the lattice mismatch at the interface of the two phases, and improve the high temperature stability of the alloy. A better understanding of the microstructure of Ni-based single crystal superalloys will provide guidance for the subsequent design of more advanced nickel-based single-crystal superalloys.

Study of Gamma/Gamma ' Interfacial Width in A Nickel-Based Superalloy by Scanning Transmission Electron Microscopy

Study Of Gamma/Gamma' Interfaces In Nickel-Based, Single-Crystal Superalloys By Scanning Transmission Electron Microscopy

Study of γ / γ ′ Interfaces in Nickel-Based, Single-Crystal Superalloys by Scanning Transmission Electron Microscopy

Mechanical Properties of Micro-phases Along < 001 > Direction of Directionally Solidified Nickel-base Super-alloy by In-situ Nano-Indentation

Interphase Interface Structure and Evolution of a Single Crystal Ni-based Superalloy Based on HRTEM Image Analysis.

RETRACTED: Atomic Scale Interfacial and Compositional Characteristics of the Σ and Γ Phases of Ni-based Single-Crystal Superalloys

First-Principles Study Of The Electronic Properties Of Gamma/Gamma ' Interface In Ni Based Superalloys

Experimental Study of As-Cast and Heat-Treated Single-Crystal Ni-Based Superalloy Interface Using TEM

Effect of Re in Gamma Phase, Gamma ' Phase and Gamma/Gamma ' Interface of Ni-Based Single-Crystal Superalloys

On the tungsten segregation at γ/γ′ interface in a Ni-based single-crystal superalloy

First-Principles Study of the Electronic Properties of γ⁄γ′ Interface in Ni Based Superalloys

Comment on "Atomic Scale Structure and Chemical Composition across Order-Disorder Interfaces"

Coupling between Re segregation and γ/γ′ interfacial dislocations during high-temperature, low-stress creep of a nickel-based single-crystal superalloy

Interaction between phase boundary and interfacial dislocations in nickel based single crystalline superalloy

Nano-cutting deformation characteristics and atomic-scale behavior of two-phase γ/γ′ nickel-based single crystal superalloy

Unveiling the Re segregation at γ/γ′ interface in Ni-based superalloy

Regular Γ/γ′ Phase Interface Instability in a Binary Model Nickel-Based Single-Crystal Alloy

Deformation Behavior of Nickel-Based Superalloys with Bimodal Γ′ Size Distribution Studied by In-Situ Neutron Diffraction Combined with Evpsc Modeling

First Principles Study of the Diffusional Phenomena Across the Clean and Re-doped Γ-Ni/γ’-ni3al Interface of Ni-based Single Crystal Superalloy

Atomic-scale Observation of the Interfaces Between Η and Γ Matrix in ATI718Plus

Effects of crack-γ/γ' interface relative distributions on the deformation and crack growth behaviors of a nickel-based superalloy