Abstract:The interface plays an important role in determining strength and toughness in multiphase systems and the accurate measurement of the interface structure in single crystal (SX) Ni-based superalloy is also essential. In this work, the γ and γ' lattice constant, γ/γ' interface width at dendritic and interdendritic region of casting and solution treatment SX Ni-based superalloy is measured. Various advanced equipment is used to characterize γ/γ' interface nanostructure. A typical correlation between interface width and γ/γ' misfit is also summarized. The interface width in the dendritic region of the as-cast sample is larger than that in the interdendritic region. The misfit in the dendritic region is larger than that in the interdendritic region, which has a trend of negative development. There is a common law of the as-cast interdendritic and dendrite interface sample, where the absolute value of the misfit between the two phases is increasing with the phase interface broadening. The comparison of the as-cast and heat-treated interdendritic sample shows that after heat treatment, the phase interface width increases, the misfit decreases, the lattice constant of γ phase increases, and the lattice constant of the γ' phase decreases. By comparing the as-cast and heat treated dendrites, the absolute value of the misfit of the as-cast dendrite sample is significantly smaller than that of the heat-treated sample, and the misfit increases with the interface broadening. The comparison between interdendritic and dendritic heat-treated samples shows that the absolute value of the misfit between the two phases is smaller than that of the dendritic as-cast samples, and the absolute value of the misfit also increases with the phase interface broadening. In conclusion, property heat treatment can significantly increase the lattice constants of the γ and γ' phases, reduce the lattice mismatch at the interface of the two phases, and improve the high temperature stability of the alloy. A better understanding of the microstructure of Ni-based single crystal superalloys will provide guidance for the subsequent design of more advanced nickel-based single-crystal superalloys.

Regular Γ/γ′ Phase Interface Instability in a Binary Model Nickel-Based Single-Crystal Alloy

Influence of Cooling Rate on the Formation of Bimodal Microstructures in Nickel-Base Superalloys During Continuous Two-Step Aging

Structural Evolution of Topologically Closed Packed Phase in a Ni-based Single Crystal Superalloy

Temperature Effects on Deformation Substructures and Mechanisms of a Ni-based Single Crystal Superalloy

The Coarsening Behavior of Γ′ Phases in Ni-Al Binary Model Single Crystal Superalloy at 1000 °C

Nano-cutting deformation characteristics and atomic-scale behavior of two-phase γ/γ′ nickel-based single crystal superalloy

Precipitation and growth behavior of γ′ phase in Ni3Al-based superalloy under thermal exposure

The change of γ' phase sizes and volume fraction in a Ni-Al binary model nickel-based single-crystal alloy during the thermal exposure treatment

Coarsening Transitional Kinetics of Γ′ Precipitates in a Nickel-Based Single Crystal Superalloy During Thermal Exposure

Evolution of phase interface microstructure and its effects on stress rupture property of a 4th generation nickel-based single crystal superalloy after thermal exposure

Effect of μ precipitation and γ′ evolution on intra/intergranular strength of Ni-Co-Cr-based superalloys after 800 °C thermal exposure

Experimental Study of As-Cast and Heat-Treated Single-Crystal Ni-Based Superalloy Interface Using TEM

Microstructure evolution behavior of Ni3Al (γ′) phase in eutectic γ-γ′ of Ni3Al-based alloy

Molecular Dynamics Simulation of Atomic Configurations at Γ/γ′ (001) Interface in Ni-based Single-Crystalline Superalloys

Misfit Dislocation Networks In The Gamma Broken Vertical Bar Gamma ' Phase Interface Of A Ni-Based Single-Crystal Superalloy: Molecular Dynamics Simulations

A Sharp-Interface Model of the Diffusive Phase Transformation in a Nickel-Based Superalloy

Effect of biphasic interface on mechanical properties and deformation mechanism of nickel base alloy

Interaction between phase boundary and interfacial dislocations in nickel based single crystalline superalloy

Misfit dislocation networks in the γ/γ' phase interface of a Ni-based single-crystal superalloy : Molecular dynamics simulations

Growth behavior of γ′ phase in a powder metallurgy nickel-based superalloy under interrupted cooling process

Atomic-scale Observation of the Interfaces Between Η and Γ Matrix in ATI718Plus