Abstract:<p>Aiming at the problem of thermal deviation in crossover pass of single tangential boiler, an on-line measurement method of radiation parameters of high temperature coal particles based on radiation spectroscopy was proposed. A measurement system consisting of an optical fiber spectrometer system and a water-cooled structure probe was developed, which was used to measure the radiation parameters of high temperature coal particles in crossover pass of the boiler. The radiation spectra at 500-1000nm band on the gas flow side of the final reheaters inlet section of a 660MW ultra-supercritical boiler were measured by the system. According to Planck's law, the distribution of coal particles temperature, emissivity and other parameters along the section was obtained by fitting parameter method. The results show that the burnout delay of pulverized coal particles caused by the air-stage combustion system and the radiant heat transfer deviation caused by the non-uniform concentration of coal particles are the main causes of the thermal deviation of the final reheaters. Under the condition of increasing yaw angle of SOFA nozzles, the ability of SOFA to alleviate the residual swirling flow is significant, and the temperature distribution of coal particles in the crossover pass is more uniform. However, due to the phenomenon of single-side particles accumulation still exists, the deviation of particles radiation intensity remains large, which cannot effectively reduce the steam temperature deviation in reheaters. Through differentially adjusting the angles of SOFA nozzles in vertical direction and horizontal direction, the phenomenon of single-side coal particles accumulation can be improved, the non-uniform radiation heat transfer of heat exchangers on both sides can be balanced, and the steam temperature deviation in final reheaters can be reduced.</p>

Measurements On Heat Flux Distribution In A Supercritical Arch-Fired Boiler

Studies on heat flux distribution on the membrane walls in a 600 MW supercritical arch-fired boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Heat Flux Distribution on Circulating Fluidized Bed Boiler Water Wall

Numerical Simulation Of Combustion Characteristics And Heat Flux Distribution In A 600-Mw Arch-Fired Boiler With Different Primary Air Injection Angles

Experimental Investigation and Model Validation of the Heat Flux Profile in a 300 MW CFB Boiler

Heat Flux Determination Based on the Waterwall and Gas–solid Flow in a Supercritical CFB Boiler

Heat Transfer Measurements Inside The Furnace Of A 135mwe Cfb Boiler

Heat flux profile of the furnace wall of a 300MWe CFB boiler

Measurement and Its Error Analysis of Heat Flux in Water Wall

Modeling Analysis and Experimental Study of a Temperature-difference Type Heat Flux Meter

Measurement of thermal deviation of flue-gas in crossover pass of single tangential boiler

Calculation on In-furnace Heat Transfer of Large (ultra)supercritical Coal-fired Boilers

Measurement of Heat Transfer in a 465t/h Circulating Fluidized Bed Boiler

Numerical Study and Structural Optimization of Water-Wall Temperature-Measurement Device for Ultra-Supercritical Boiler

Heat Transfer Coefficient Distribution in the Furnace of a 300MWe CFB Boiler

Heat transfer in a 600 Mwe supercritical circulating fluidized bed boiler with water cooled wall panels

Heat transfer characteristic of water wall and partition wall in a 600 MW CFB boiler

Numerical Study of Supercritical Opposed Wall-Fired Boiler Furnace Temperature and High-Temperature Heating Surface Stress under Variable Load Operation

A Method to Measure the Tube-Wall Temperature in CFB Boilers

Measurement of particle density distribution near water wall of a 330 MW unit CFB boiler