Abstract:Synthetic tetrahedrite (Cu12Sb4S13) is considered a promising p-type thermoelectric material owing to its intrinsically low thermal conductivity, relative nontoxicity, and presence of light elements Cu and S. Since Cu12Sb4S13 has a high carrier (hole) concentration, its power factor can be optimized by decreasing the carrier concentration via doping. In this study, Zn doping is performed to optimize the power factor by reducing the carrier concentration, and Bi doping is performed to reduce the lattice thermal conductivity through additional phonon scattering by atomic mass fluctuation and lattice distortion. Cu12−xZnxSb4−ySbyS13 tetrahedrites (0.1 ≤ x ≤ 0.4 and 0.1 ≤ y ≤ 0.4) were prepared using mechanical alloying and hot pressing, and the effects of double doping of Zn and Bi on the charge transport and thermoelectric properties were examined. X-ray diffraction analysis revealed the successful formation of the tetrahedrite phase, but a small amount of skinnerite phase (Cu3SbS3) was produced with an increase in the Bi content. The lattice constant increased with an increase in Zn and Bi doping contents, as the ionic radii of Zn and Bi were larger than those of Cu and Sb, respectively. With an increase in the Zn content and a decrease in the Bi content, the carrier concentration decreased. Consequently, the electrical conductivity decreased, whereas the Seebeck coefficient increased. The decline in the electrical conductivity with Zn doping dominated the increase in the Seebeck coefficient, which in turn reduced the power factor. However, the power factor did not change significantly with a change in the Bi content. The lattice thermal conductivity was close to the theoretical minimum value in tetrahedrite upon substituting with Zn and Bi, and thus, the thermal conductivities of all the specimens were less than 0.94 Wm−1 K−1 at temperatures ranging from 323 to 723 K. Consequently, the dimensionless figure of merit, ZT = 0.77, was obtained for Cu11.9Zn0.1Sb3.9Bi0.1S13 at 723 K, which was attributed to a relatively high power factor (0.83 mWm−1 K−2) and low thermal conductivity (0.76 Wm−1 K−1).

CuPbBi<sub>5</sub>S<sub>9</sub> thermoelectric material with an intrinsic low thermal conductivity: Synthesis and properties

Origin of Low Lattice Thermal Conductivity in Promising Ternary PbmBi2S3+m (m = 1-10) Thermoelectric Materials

A Tunable Structural Family with Ultralow Thermal Conductivity: Copper-Deficient Cu1–x□xPb1–xBi1+xS3

Synergistically enhanced thermoelectric properties of Bi2S3 bulk materials via Cu interstitial doping and BiCl3 alloying

Pb m Bi 2 S 3+ m Homologous Series with Low Thermal Conductivity Prepared by the Solution-Based Method as Promising Thermoelectric Materials

Enhanced thermoelectric performance of Bi<sub>2-x</sub>Cu<sub>x</sub>S<sub>3</sub> by hydrothermal synthesis and spark plasma sintering

Bi and Sn Co-Doping Enhanced Thermoelectric Properties of Cu3SbS4 Materials with Excellent Thermal Stability.

Planar Zintl-phase high-temperature thermoelectric materials XCuSb (X = Ca, Sr, Ba) with low lattice thermal conductivity

Cu4Bi4Se9: A Thermoelectric Symphony of Rattling, Anharmonic Lone-pair, and Structural Complexity.

Enhanced thermoelectric performance of Bi2-xCuxS3 by hydrothermal synthesis and spark plasma sintering

Quasi-layered Crystal Structure Coupled with Point Defects Leading to Ultralow Lattice Thermal Conductivity in n-Type Cu 2.83 Bi 10 Se 16

PbmBi2S3+m Homologous Series with Low Thermal Conductivity Prepared by the Solution-Based Method As Promising Thermoelectric Materials

Unlocking the Potential of Cu3SbSe3: Ultralow Thermal Conductivity and Enhanced Thermoelectric Performance

Thermoelectric Properties of Low Te Concentration‐Doped Cu2ZnSnSe4‐Based Quaternary Alloys

Electronic Transport and Thermoelectric Properties of Cu12-xZnxSb4S13 Tetrahedrites Prepared by Mechanical Alloying and Hot Pressing

Enhanced Thermoelectric Properties Obtained by Compositional Optimization in P -Type Bi X Sb 2− X Te 3 Fabricated by Mechanical Alloying and Spark Plasma Sintering

Effects of Zn/Bi Double Doping on the Charge Transport and Thermoelectric Properties of Tetrahedrites Cu 12− X Zn X Sb 4− Y Bi Y S 13

Thermoelectric Cu12 Sb4 S13 -Based Synthetic Minerals with a Sublimation-Derived Porous Network.

Synthesis and Transport Properties of Agbi3s5 Ternary Sulfide Compound

The New Thermoelectric Semiconductors Pb5Sb12+xBi6−xSe32 with Ultralow Thermal Conductivity

Enhanced Thermoelectric Properties of Cu3SbSe4 Compounds by Isovalent Bismuth Doping