Abstract:Hydrophobic symmetric flat-sheet membranes of polyvinylidene fluoride (PVDF) for use in vacuum membrane distillation (VMD) were successfully fabricated by the vapor-induced phase separation (VIPS) method using the double-layer casting process. To avoid the delamination that often occurs in double-layered membranes, the same PVDF polymer was employed in both the upper layer and support layer casting solutions. Solutions with low and high PVDF contents were co-cast as the upper layer and support layer of the membrane that was formed. In the VIPS process, the low PVDF content solution favored the formation of a layer with a porous and hydrophobic surface, whereas the solution with a high PVDF concentration favored the formation of a layer with high mechanical strength. The effect of the vapor-induced time on the morphological properties of the membranes was studied. As the vapor-induced time was increased, the cross-section of the membrane changed from an asymmetrical finger-like structure to a symmetrical sponge-like structure, and the surface of the membrane became rough and porous. The membrane subjected to the longer vapor-induced time also exhibited a higher permeating flux during the VMD process. The best PVDF membrane fabricated in this study had a mean radial pore size of 0.49 μm, and the rough upper surface produced a static contact angle of 145° with water. During the VMD process with a 3.5 wt.% sodium chloride (NaCl) aqueous solution, the best membrane that was fabricated produced a permeating flux of 22.4 kg m −2 h −1 and an NaCl rejection rate of 99.9 % at a feed temperature of 73 °C and a downstream pressure of 31.5 kPa. This performance is comparable to or superior to the performances of most of the flat-sheet PVDF membranes reported in the literature and a polytetrafluoroethylene membrane used in this study.

Preliminary Research on Effect Factors of Permeation Flux of PVDF Microporous Hollow Fiber Membrane

Effect of the Permeants/Polymer Interactions on the Pervaporative Separation Properties of the P(Vdf-Co-Hfp) Membrane

Effect of Spinning Conditions on the Structure and Performance of Hydrophobic PVDF Hollow Fiber Membranes for Membrane Distillation

Preparation and Characterization of PVDF/nonwoven Fabric Flat-Sheet Composite Membranes for Desalination Through Direct Contact Membrane Distillation

Preparation and characterization of PDMS-PVDF hydrophobic microporous membrane for membrane distillation

EFFECTS OF POLYMER MOLECULAR WEIGHT ON PVDF MICROFILTRATION MEMBRANE PERFORMANCE BY IMMERSION PRECIPITATION PHASE INVERSION

EFFECTS OF CASTING CONDITIONS ON PVDF MICROFILTRATION MEMBRANE PERFORMANCE BY IMMERSION PRECIPITATION PHASE INVERSION

Effect of Polymer Content on the Properties of PVDF Electro-spinning Nanofiber Membrane for Membrane Distillation

STUDY ON THE PREPARATION OF PVDF MICROPOROUS HOLLOW FIBER MEMBRANE

Water Flux Enhancement of PVDF Membrane by a Facile Coating Method for Vacuum Membrane Distillation

Effects of polyvinylidene fluoride hydrophobic hollow fiber membrane and module on the performance of vacuum membrane distillation process

Study on the effect of air gap on physico-chemical and performance of PVDF hollow fibre membrane

Preparation and characterization of polyvinylidene fluoride (PVDF) hollow fiber membranes

PREPARATION AND PERFORMANCE OF PVDF MEMBRANES FABRICATED BY PVDF-SOLVENT-NON-SOLVENT-ADDTIVE SYSTEMS

Preparation and modification of PVDF membrane via VIPS method for membrane distillation

Development of preparation techniques for polyvinylidene fluoride(PVDF) microporous membranes

Occurrence of Salt Breakthrough and Air-Vapor Pocket in a Direct-Contact Membrane Distillation

Diverse Morphologies of PVDF Hollow Fiber Membranes and Their Performance Analysis As Gas/liquid Contactors

Preparation and characterization of hydrophobic PVDF membranes by vapor-induced phase separation and application in vacuum membrane distillation

Effects of solvent compositions on physicochemical properties and anti-fouling ability of PVDF microfiltration membranes for wastewater treatment

Microstructures and Properties of PVDF Membranes: Effect of the Solvent