Abstract:The powertrain electrification is an effective solution to emission reduction of mobile machines. To overcome the low power density of electric drive, a hydraulic accumulator is introduced as a supplementary power source. In this paper an electric-hydraulic hybrid powertrain solution is studied for wheel loader propulsion system, where it combines the energy density of electric drive and high power density of hydraulic drive. The energy management strategy is essential for hybrid powertrain since it determines how efficiently the power is transferred between different energy sources. In this paper a mode-driven control strategy for electric-hydraulic hybrid wheel loader is proposed to achieve electric power reduction over power follower strategy (baseline strategy), without sacrificing electric energy use and vehicle operation hours. In the strategy four modes are defined and the expected hydraulic SOC (system pressure) profile in each mode is scheduled to provide supplementary power assist and capture regenerative braking energy. By setting the pressure profile, the hydraulic charge sustaining is guaranteed. The system operation with mode-driven strategy is compared with power follower strategy through simulation studies. Results show that peak powers of battery and electric motor with mode-driven strategy are reduced by nearly 30% compared to power follower strategy. Results also show that the vehicle operation hour has been slightly increased by 3% by using mode-driven strategy. These results verify the effectiveness of proposed strategy for electric-hydraulic hybrid wheel loader.

A Research on the Control Strategy for Engine Starting While Driving in a Full Hybrid Power System with Single Motor

Research on Modeling and Control Strategy of Parallel Hybrid Power System in Excavator

Control Strategy of Hybrid Excavator Based on Condition Recognition and Hybridization Optimization

Control Strategy for a Full Hybrid Vehicle with Single Motor

The Control Strategy for a New Full Hybrid Powertrain Structure

Integrated Motion and Powertrain Predictive Control of Intelligent Fuel Cell/Battery Hybrid Vehicles

The Coordinated Control Strategy of Engine Starting Process in Power Split Hybrid Electric Vehicle Based on Load Observation

Analysis and Control of Engine Starting Process Based on a Novel Single-Motor Power-Reflux Hybrid Electric Vehicle

Dynamic Coordinated Control for a Full Hybrid Electric Vehicle with Single Motor

Hierarchical control for a full hybrid vehicle with single motor and double clutches

Coordinated Clutch Slip Control for the Engine Start of Vehicles with P2-hybrid Automatic Transmissions

Research on the Energy Control of a Dual-Motor Hybrid Vehicle During Engine Start-Stop Process

Active Damping Control of Start-up Process for Hybrid Vehicle

Dynamic coordinated control strategy of a dual-motor hybrid electric vehicle based on clutch friction torque observer

Torque coordinating robust control of shifting process for dry dual clutch transmission equipped in a hybrid car

A Moment-of-Inertia-Driven Engine Start-Up Strategy for Four-Wheel-Drive Hybrid Electric Vehicles

Research on the Control Systems for Hybrid and Electric Powertrains

An Electric-Hydraulic Hybrid Wheel Loader with Mode-Driven Control Strategy

A Dynamic Coordinated Control Strategy for Mode-Switch of Hybrid Electric Vehicle Based on the Effect Control

Optimal Engine Starts of an Input-Split Hybrid Electric Vehicle

Hierarchical Control of Starting Process for Wet Dual Clutch Transmission Based on Direct-Drive Pump-Controlled Hydraulic Actuator