Abstract:The powertrain electrification is an effective solution to emission reduction of mobile machines. To overcome the low power density of electric drive, a hydraulic accumulator is introduced as a supplementary power source. In this paper an electric-hydraulic hybrid powertrain solution is studied for wheel loader propulsion system, where it combines the energy density of electric drive and high power density of hydraulic drive. The energy management strategy is essential for hybrid powertrain since it determines how efficiently the power is transferred between different energy sources. In this paper a mode-driven control strategy for electric-hydraulic hybrid wheel loader is proposed to achieve electric power reduction over power follower strategy (baseline strategy), without sacrificing electric energy use and vehicle operation hours. In the strategy four modes are defined and the expected hydraulic SOC (system pressure) profile in each mode is scheduled to provide supplementary power assist and capture regenerative braking energy. By setting the pressure profile, the hydraulic charge sustaining is guaranteed. The system operation with mode-driven strategy is compared with power follower strategy through simulation studies. Results show that peak powers of battery and electric motor with mode-driven strategy are reduced by nearly 30% compared to power follower strategy. Results also show that the vehicle operation hour has been slightly increased by 3% by using mode-driven strategy. These results verify the effectiveness of proposed strategy for electric-hydraulic hybrid wheel loader.

The Control Strategy for a New Full Hybrid Powertrain Structure

Control Strategy for a Full Hybrid Vehicle with Single Motor

Control Strategy of Hybrid Excavator Based on Condition Recognition and Hybridization Optimization

Hierarchical control for a full hybrid vehicle with single motor and double clutches

Integrated Motion and Powertrain Predictive Control of Intelligent Fuel Cell/Battery Hybrid Vehicles

An Electric-Hydraulic Hybrid Wheel Loader with Mode-Driven Control Strategy

Dynamic Coordinated Control for a Full Hybrid Electric Vehicle with Single Motor

Research on the Control Systems for Hybrid and Electric Powertrains

Fuzzy Control Strategy For A Tri-Energy Hybrid Bus

Development of Hybrid Powertrain Control Software

Energy Management Strategy of Dual Drive Hybrid Electric Vehicle

A Dynamic Coordinated Control Strategy for Mode-Switch of Hybrid Electric Vehicle Based on the Effect Control

A New Control Strategy for Power Management of Fuel-Cell-Battery Hybrid Vehicles

Robust Coordinated Control for Hybrid Electric Bus with Single-Shaft Parallel Hybrid Powertrain

CONTROL STRATEGY FOR A NON-HYBRID HYDROSTATIC TRANSMISSION CONSTRUCTION VEHICLE BASED ON POWER FOLLOWER

The Coordinated Control Strategy of Engine Starting Process in Power Split Hybrid Electric Vehicle Based on Load Observation

Research on Modeling, Simulation and Control of New Type Power Split Hybrid Powertrain

The Structure and Control Method of Hybrid Power Source for Electric Vehicle

Torque coordinating robust control of shifting process for dry dual clutch transmission equipped in a hybrid car

Innovative Design And Coordinated Control Of Multi-Mode Coupling Drive System With A Speed-Up Clutch For Plug-In Hybrid Electric Vehicles

Economical Launching and Accelerating Control Strategy for a Single-Shaft Parallel Hybrid Electric Bus