Abstract:The effects of trace transition elements (Mn, Cr, V) on the solidification microstructure and the thermal conductivity of Al-9Si based alloys have been investigated. It was found that the effect of Mn, Cr, V on the solidification behavior and solidification microstructure is mainly related to α-Al grains via affecting heterogeneous nucleation and growth restriction, while no significant effect on the solidification behavior and microstructure of eutectic Si was observed. Compared with factors including grain size of α-Al and morphology characteristics (e.g. size, spacing, and shape factor) of eutectic Si, the solid solubility in Al matrix is confirmed to be one of the most important factors affecting thermal conductivity. Due to the larger partition coefficient of V compared with Cr and Mn, the solid solubility and the lattice distortion of α-Al in Al-9Si-xV alloy were increased significantly, thus the thermal conductivity of alloy was decreased steeply from 171.7 to 152.3 W/m·K with the content of V increasing from 15 to 1010 ppm. A linearly fitted curve reflecting the relationship between the content of the transition elements and the thermal conductivity of alloys has been proposed, which can be used to optimize the alloy composition in subsequent remelting or recycling process. Furthermore, two thermal conductivity models (H-S model and Maxwell model) also have been used to evaluate the effect of Mn, Cr, V on thermal conductivity, in which the thermal conductivity of α-Al was corrected based on the measured solid solubility. In this way, the data correlation between the experimental and fitted value based on H-S model and Maxwell model is increased from 0.18 to 0.96. These obtained results could be helpful to precisely control the composition and further improve the thermal conductivity of Al-Si based alloy during the primary production and / or recycling process.

Thermodynamics of effect of modification on microstructure of Al-Si alloy melt

Thermal stability and its effects on the mechanical properties of rapidly solidified Al-Ti alloys

The Effect of Solution Treatment on the Si Particles’ Morphology Evolution and the Thermal Conductivity and Tensile Properties of Sb-Modified Al-8Si-0.6Mg Alloys

Effects of Refinement and Modification on Melt Structure of Hypoeutectic Al-Si Alloy

Electrical resistivity and structural heredity of hypereutectic Al-Si alloy melt

Modification mechanism and tensile property of Al-9Si-0.4Mg-0.1Cu alloy

Physical properties and solidification structure of Al-Si eutetic alloy melt with cerium modification

Physical properties and solidification structure of Al-Si eutectic alloy melt with cerium modification

Effect of modification and subsequent heat treatment on thermal and mechanical properties of near-eutectic Al-Si-Fe-Mg alloys

Investigation on Structures of Aluminum Melts Containing Small Amount of Silicon Element

Thermodynamic Effects of Alloying Elements on Solid-State Interfacial Reactions in a Multicomponent System: Theoretical Treatment and Application in SiC f /Ti Composites

The evolution on the microstructure and thermal expansion behavior of Al–50Si alloy with different P contents

Effects of Zr,Ti and Sc Additions on the Microstructure and Mechanical Properties of Al-0.4Cu-0.14Si-0.05Mg-0.2Fe Alloys

Effect of Mischmetal Modification Treatment on the Microstructure, Tensile Properties, and Fracture Behavior of Al-7.0%Si-0.3%Mg Foundry Aluminum Alloys

Effect of microstructures on mechanical properties of Ti‐6.5Al‐2Sn‐4Zr‐4Mo‐1W‐0.2Si alloy

Effect of Sr Modification on the Microstructures, Mechanical Properties, and Thermal Conductivity of Hypoeutectic Al-13.6Cu-6Si Alloys

Constitutive relation between electric conductivity and microstructure characteristics parameters of hypoeutectic Al-Si alloys

The Influence of Al–10Sr Or/ and Al–5Ti–1B on Microstructure and Mechanical Properties of Al–12Si–4Cu–2Ni–0.8 Mg Alloys

Effects of metalloid Si on the microstructure and mechanical properties of Fe36Ni36Cr10Mo1Al17-XSiX alloys

Elucidating thermal conductivity mechanism of Al-9Si based alloys with trace transition elements (Mn, Cr, V)

Effects of Solution Treatment on Microstructure and Properties of Al-Mg-Si-Mn alloy