Mechanical Anisotropy Induced by the Competition Between Twinning and Basal Slip of AZ31 Magnesium Alloy under Biaxial Tension
Yao Cheng,Hua Qiao,Yuanjie Fu,Yunchang Xin,Qiuju He,Xinde Huang,Gang Chen,Peidong Wu,Qing Liu
DOI: https://doi.org/10.1016/j.ijplas.2024.104005
IF: 8.5
2024-01-01
International Journal of Plasticity
Abstract:The mechanical behavior of a hot-rolled Mg AZ31 plate was studied under biaxial tensions along two perpendicular loading axes of x and y in the ND-TD plane, with the x-axis aligned at a 45 degrees counterclockwise angle from the TD (ND and TD refer to the normal direction and transverse direction). A complex strain partitioning in two loading axes is observed with the variation of stress ratio sigma(xx) : sigma(yy). For sigma(xx) : sigma(yy) = 1:1 and 1:1.5, the strains along the x- and y-axes, epsilon(xx) and epsilon(yy), are both positive. However, With the stress ratio of sigma(xx) : sigma(yy) = 1:3, epsilon(yy) remains positive, while epsilon xx becomes negative. Interestingly, for sigma(xx) : sigma(yy) = 1:2, epsilon(xx) changes from negative during the early stage of loading to positive upon failure. Crystal plasticity simulations and theoretical calculations reveal that the observed strain transition. The reasons for the strain transition with stress ratio is related to the competition between {10(1) over bar2} twinning and basal slip. For {10(1) over bar2} twinning, the accommodated strains by most of the twins are epsilon(xx)>0 and epsilon(yy)>0 for all the stress ratios considered. For basal slip, most of the basal variants accommodate a positive y-axis strain, while for loading cases with low stress ratios, most of the basal variants result in a negative x-axis strain. As the stress ratio decreases, basal slip becomes more active, while the activity of {10(1) over bar2} twinning gradually decreases, leading to the observed strain transition. For sigma(xx) : sigma(yy) = 1:2, the transition from negative to positive is related to the increasing activity of {10(1) over bar2} twinning with strain. Theoretical calculations reveal that the competition of basal slip and {10(1) over bar2} twinning under biaxial tension is determined by the variation of their Schmid factors with sigma(xx) : sigma(yy).