Abstract:A method for the preparation of polyimide (PI) nanofoams with high thermal stability, which can be used as dielectric layers in microelectronics, has been presented in this paper. Polystyrene (PS) and poly[styrene-co-(4-vinylpyridine)] (PSVP) nanospheres were prepared by emulsion polymerization. The diameter of these particles was 30 to 40 nm. PMDA-ODA PI nanocomposite films with various contents of PS and PSVP were obtained by in-situ condensation polymerization in the presence of nanospheres. The distribution of the nanospheres in the films and the morphology of the films were characterized by TEM. Relatively homogeneous distributions were observed for the PI/PSVP nanocomposite films, which can be ascribed to the formation of poly(amic acid) amine salts between pyridinyl and carboxyl moieties. The transport properties of CO2, O-2 N-2, and CH4 gases through these nanocomposite films were measured. For the PI/PS-nanosphere composite films, with the increase of PS nanospheres in the films, the gas permeabilities increased and selectivities decreased: these were due to the increase in gas diffusion coefficients and the decrease in diffusion selectivities. For PI/PSVP-nanosphere composite films, increases in both gas permeabilities and selectivities were observed when the PSVP-nanospheres increased from 10 to 20 wt% in the films, while both the diffusion coefficients and diffusion selectivities decreased. It was found that the membrane containing 20 wt% PSVP-nanospheres showed both high gas permeability and high permselectivity toward CO2. These results can be ascribed to the high solubility of CO2 and 0, in the pyridine-containing polymers and the relatively homogenous distribution of PSVP-nanospheres in the PI matrix. Upon thermal treatment, the thermally unstable nanospheres undergo thermolysis, leaving pores with the size and shape dictated by the initial nanosphere morphology. The resulted foams were characterized by TEM, DSC, TG, density measurements and dielectric constant measurements. The results revealed that nanofoams with high thermal stability and low dielectric constant approaching 2.0 could be prepared using PI nanocomposite approach.

Novel PMDA-ODA Polyimide / Polystyrene Nanocomposite Membranes for Carbon Dioxide Separation

CO2 Facilitated Transport Through an Acrylamide and Maleic Anhydride Copolymer Membrane

Gas separation properties of PMDA/ODA polyimide membranes filling with polymeric nanoparticles

Selective Permeation of CO2 Through a Composite Membrane with a Separation Layer of 2-N,n-dimethyl Aminoethyl Methacrylate and Acrylic Acid Copolymer

Polyimide/Polystyrene Nanocomposite Films As Membranes For Gas Separation And Precursors For Polyimide Nanofoams

Pebax-derived Ultra-Microporous Carbon Molecular Sieve Composite Membrane Assisted by Organic Interlayer for Gas Separation

Poly (Vinyl Alcohol) Composite Membrane with Polyamidoamine Dendrimers for Efficient Separation of CO2/H2 and CO2/N2

Carbon molecular sieve hollow fiber composite membrane derived from PMDA-ODA polyimide for gas separation

Sorption Behavior and Separation Performance of Novel Facilitated Transport Membranes for CO2/CH4 Mixtures

Enhanced polyphosphazene membranes for CO2/CH4 separation via molecular design

Poly ether block Amide/Polyvinyl Alcohol/ MgO nanocomposite membranes: Selectivity for CO 2 and CH 4 gases

Preparation and Characterization of HEMA-co-VAm/PDA@GO/PSf Membrane with Enhanced CO2 Separation

Improving gas permeation performance of PDMS by incorporating hollow polyimide nanoparticles with microporous shells and preparing defect-free composite membranes for gas separation

Preparation and Separation Performance of PDMS Composite Membranes for CO2 Separation from CO2-DMC System

Preparation and gas separation properties of PDMS composite membrane materials

Improving the Selectivity of ZIF-8/Polysulfone-Mixed Matrix Membranes by Polydopamine Modification for H2/CO2 Separation

High-efficiency CO2 separation using hybrid LDH-polymer membranes

Double-decker-shaped phenyl-substituted silsesquioxane (DDSQ)-based nanocomposite polyimide membranes with tunable gas permeability and good aging resistance

CO2/N2 Separation Using Polyvinyl Chloride Iso-Phthalic Acid/Aluminium Nitrate Nanocomposite Membrane

Preparation and Performance Evaluation of an Asymmetric Polyimide Membrane Used in a Novel Solvent Absorption-Membrane Desorption CO 2 Capture

Preparation and Performance Evaluation of an Asymmetric Polyimide Membrane Used in a Novel Solvent Absorption-Membrane Desorption CO2 Capture