Abstract:A multistep diffusion-mediated process was developed to control the nucleation density, size, and lateral growth rate of WSe2 domains on c-plane sapphire for the epitaxial growth of large area monolayer films by gas source chemical vapor deposition (CVD). The process consists of an initial nucleation step followed by an annealing period in H2Se to promote surface diffusion of tungsten-containing species to form oriented WSe2 islands with uniform size and controlled density. The growth conditions were then adjusted to suppress further nucleation and laterally grow the WSe2 islands to form a fully coalesced monolayer film in less than 1 h. Postgrowth structural characterization demonstrates that the WSe2 monolayers are single crystal and epitaxially oriented with respect to the sapphire and contain antiphase grain boundaries due to coalescence of 0 degrees and 60 degrees oriented WSe2 domains. The process also provides fundamental insights into the two-dimensional (2D) growth mechanism. For example, the evolution of domain size and cluster density with annealing time follows a 2D ripening process, enabling an estimate of the tungsten-species surface diffusivity. The lateral growth rate of domains was found to be relatively independent of substrate temperature over the range of 700-900 degrees C suggesting a mass transport limited process, however, the domain shape (triangular versus truncated triangular) varied with temperature over this same range due to local variations in the Se/W adatom ratio. The results provide an important step toward atomic level control of the epitaxial growth of WSe2 monolayers in a scalable process that is suitable for large area device fabrication.

Direct Growth of Antimonene on C-Plane Sapphire by Molecular Beam Epitaxy

Epitaxial growth of highly strained antimonene on Ag (111)

Modulating Epitaxial Atomic Structure of Antimonene Through Interface Design.

Recent progress on antimonene: from theoretical calculation to epitaxial growth

Epitaxial growth and E-beam induced structural changes of single crystalline 2D antimonene

Phase-Dependent Epitaxy for Antimonene Growth on Silver Substrate

Large‐Scale Synthesis of Strain‐Tunable Semiconducting Antimonene on Copper Oxide

Epitaxial Growth of Flat Antimonene Monolayer: A New Honeycomb Analogue of Graphene

Old materials with new properties III: Antimony

Epitaxy of Antimonene Thin Films with Screw Dislocations for the Application of Saturable Absorbers

Two-dimensional antimonene single crystals grown by van der Waals epitaxy

Molecular Beam Epitaxy Of Highly Crystalline Monolayer Molybdenum Disulfide On Hexagonal Boron Nitride

Van der Waals Heteroepitaxial Growth of Monolayer Sb in a Puckered Honeycomb Structure

Vapor phase epitaxy of antimonene-like nanocrystals on germanium by an MOCVD process

Fabrication and Characterization of Silicon-Based Antimonene Thin Film via Electron Beam Evaporation

Epitaxial Growth of Large-Scale α-Phase Antimonene

Surface Step Edge-Assisted Monolayer Epitaxy of Α-Antimonene on SnSe2 Substrate

Monomolecular Membrane-Assisted Growth of Antimony Halide Perovskite/MoS 2 Van der Waals Epitaxial Heterojunctions with Long-Lived Interlayer Exciton

Diffusion-Controlled Epitaxy of Large Area Coalesced WSe2 Monolayers on Sapphire

Epitaxial growth of atomically thin Ga2Se2 films on c-plane sapphire substrates

Antimonene with Topological Nontrivial Band Structure on Al(111) Substrate