Abstract:Numerical simulations were conducted to study the effects of the pulverized-coal bias distribution in the primary air on the coal combustion and NOx generation characteristics of a 600-MW down-fired boiler with multiple-injection and multiple-staging combustion technology. The total pulverized-coal in the primary air was kept constant, and the ratio of the pulverized-coal mass flux in the fuel-rich coal/air flow to the total pulverized-coal mass flux (RPR) was set as 60%, 70%, 80%, and 90%. By changing the RPR, the excess air coefficient of the fuel-rich flow was adjusted from 0.700 to 0.467. It was found that numerical simulation results were almost in agreement with cold modeling and in situ experimental results respectively, including the flow fields in the lower furnace at the RPR of 80% and the heating processes for the fuel-rich coal/air flow at the RPR of 90%, which verified the rationality of the numerical model and the grid. The simulation results indicated that the change of RPR has little effect on the symmetry of the flow field in the furnace. With the increase of the RPR from 60 to 90%: (1) the maximum airflow declination angle near the tertiary air slot decreased from 71 to 66°, which indicates that the downward airflow penetration depth gradually decreased; (2) the ignition distance of the fuel-rich coal/air flow decreased from 1.2 to 0.9 m, and the high-temperature area in the furnace hopper decreased and the position gradually moved away from the hopper water walls; (3) the oxygen consumption rate at the initial combustion stage constantly accelerated, and the fuel NOx generation rate under the fuel-rich flow nozzle increased first and then decreased; (4) the NOx emissions at the furnace exit dropped from 778 to 662 mg/m3 at 6% O2, and the carbon in the fly ash decreased from 5.87 to 5.52%. Increasing the RPR reasonably controlled the excess air coefficient of the fuel-rich flow, and realized the high-efficiency combustion in the furnace and the reduction of NOx emissions simultaneously.

Numerical Research on the Influence of Declination Angle on Carrying Capacity of Tertiary Air, Ignition, and Combustion Characteristics of Pulverized Coal of 300 MW Down-Fired Utility Boiler with Multi-Injection and Multi-Staging Combustion Technology

Influence of Declivitous Secondary Air on Combustion Characteristics of a Down-Fired 300-Mwe Utility Boiler

Investigations on combustion optimization and NOX reduction of a 600-MWe down-fired boiler: Influence of rearrangement of tertiary air and jet angle of secondary air and separated over-fire air

Influence of secondary air declivitous angle on flow characteristics and coal combustion of a down-fired boiler

Experimental research on the fire-carrying problems in primary air nozzle of 125 MW units

ICOPE-15-C078 Effects of Vent Air Angles on Combustion and NO Emission Characteristics for a Down-Fired 600MW Pulverized-Coal Utility Boiler Retrofitted with a Novel Combustion System

Influence of Vertical Burner Tilt Angle on the Gas Temperature Deviation in a 700 MW Low NOx Tangentially Fired Pulverised-Coal Boiler

CFD modeling of hydrodynamics, combustion and NOx emission in a tangentially fired pulverized-coal boiler at low load operating conditions

Numerical Investigation of Different Burner Arrangement on A Coal-Fired Boiler

Experimental Study and Numerical Simulation on Tertiary Air Reburning with Different Micronized Coal Content

Numerical simulation on effect of burner tilting up angle on reheat steam temperature deviation for tangentially fired pulverized-coal boiler

Tertiary air operation optimization aiming at low NOx combustion in boiler

Effects of burner tilt angle on the combustion and NOX emission characteristics of a 700 MWe deep-air-staged tangentially pulverized-coal-fired boiler

Tertiary-air Effects on Combustion and NOx Emission in Tangentially Fired Furnace

Numerical Simulation Of Combustion Characteristics And Heat Flux Distribution In A 600-Mw Arch-Fired Boiler With Different Primary Air Injection Angles

Numerical simulation investigations into the influence of the mass ratio of pulverized-coal in fuel-rich flow to that in fuel-lean flow on the combustion and NOx generation characteristics of a 600-MW down-fired boiler

B215 NUMERICAL SIMULATIONS OF COMBUSTION OPTIMIZAITON FOR A 600 MW TENGENTIALLY COAL-FIRED SUPER-CRITICAL BOILER(Combustion-8)

Experimental Study on Micronized Coal Reburning for a 200MW Coal-fired Boiler

Numerical Simulations Of Combustion Optimizaiton For A 600 Mw Tengentially Coal-Fired Super-Critical Boiler

Tertiary Air Operation Optimization Aiming at Low NO_x Combustion in Boiler

Influence of Separated Overfire Air Ratio and Location on Combustion and NOx Emission Characteristics for a 600 MWe Down-Fired Utility Boiler with a Novel Combustion System