Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Performance Enhancement in InZnO Thin-Film Transistors with Compounded ZrO2–Al2O3 Nanolaminate As Gate Insulators

Fully solution-induced high performance indium oxide thin film transistors with ZrOx high-k gate dielectrics

ZrO2 Insulator Modified by a Thin Al2O3 Film to Enhance the Performance of InGaZnO Thin-Film Transistor

Feasibility of Atomic Layer Deposited AlZrOx Film to Achieve High Performance and Good Stability of ZnSnO-TFT

High Performance ZnSnO Thin Film Transistor with ZrO2 Gate Insulator Formed by Atomic Layer Deposition

Atomic Layer Deposition Deposited High Dielectric Constant (κ) ZrAlOx Gate Insulator Enabling High Performance ZnSnO Thin Film Transistors

Solution-Processed Indium-Zinc-Oxide Thin-Film Transistors Based On Anodized Aluminum Oxide Gate Insulator Modified With Zirconium Oxide

High-Performamce Amorphous Ingazno Thin-Film Transistor with Zrlao Gate Dielectric Fabricated at Room Temperature

Atomic Layer Deposited Zr x Al 1−x O y Film as High κ Gate Insulator for High Performance ZnSnO Thin Film Transistor

The Al2O3 Gate Insulator Modified by SiO2 Film to Improve the Performance of IGZO TFTs

Performance Enhancement of Solution-Processed InZnO Thin-Film Transistors by Al Doping and Surface Passivation

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Bias Stability Enhancement in Thin-Film Transistor with a Solution-Processed ZrO2 Dielectric As Gate Insulator

Enhanced Stability Performance of Transparent Ozone ALD ZnO Thin-Film Transistors with SiAlOX Dielectric

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Low-voltage, Solution-Processed InZnO Thin-Film Transistors with Enhanced Performance Achieved by Bilayer Gate Dielectrics

The influence of SiO2 and Al2O3 gate insulator to the performance of In-Ga-Zn-O thin film transistors

High-Performance Unannealed A-Ingazno Tft with an Atomic-Layer-Deposited Sio2 Insulator

Effect of Gate Insulator Thickness on Device Performance of Ingazno Thin-Film Transistors

Performance Optimization of Atomic Layer Deposited ZnO Thin-Film Transistors by Vacuum Annealing