Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

High-Source–Drain Voltage-Induced Reliability Issues of Sub-28-nm Node MOSFET’s Application in Resistive-Type Nonvolatile Memory Array

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

A Viable Self-aligned Bottom-Gate MOSFET Technology for High Density and Low Voltage SRAM

Back-Side Stress to Ease p-MOSFET Degradation on e-MRAM Chips

Effects of Non-Fatal Electrostatic Discharge on the Threshold Voltage Degradation in Nano CMOS Devices

New Observations of FN Stress Induced Performance Degradation of RF MOSFETs

Degradation of Gate Voltage Controlled Multilevel Storage in One Transistor One Resistor Electrochemical Metallization Cell

Reliability-Improved Read Circuit and Self-Terminating Write Circuit for STT-MRAM in 16 nm FinFET

On the Assessment of End-of-life Variability Induced by Stochastic NBTI in Nanoscale MOSFETs Accompanying Conspicuous RTN

Experimental insights on the degradation and recovery of pMOSFET under non-uniform NBTI stresses

Drain bias effects on statistical variability and reliability and related subthreshold variability in 20-nm bulk planar MOSFETs

Ultralow Set Voltage and Enhanced Switching Reliability for Resistive Random-Access Memory Enabled by an Electrodeposited Nanocone Array.

24.2 A 14nm-FinFET 1Mb Embedded 1T1R RRAM with a 0.022µm<sup>2</sup> Cell Size Using Self-Adaptive Delayed Termination and Multi-Cell Reference

Performance Variation of Nano-Scaled Devices in 3D-IC Packaging Architecture Induced by TSV Residual Stress

Comprehensive Study of NBTI and Off-State Reliabilty in Sub-20 Nm DRAM Technology: Trap Identification, Compact Aging Model, and Impact on Retention Degradation

Characteristics Of N-Mosfets With Stress Effects From Neighborhood Devices

Negative constant voltage stress-induced threshold voltage instability in hydrogen-terminated diamond MOSFETs with low-temperature deposited Al 2 O 3

Novel 15T SRAM Cell for Low Voltage High Reliability Application

Nano-scaled Transistor Reliability Characterization at Nano-Second Regime

Electrical Stress on the CMOS Inverters Made by Junctionless Gate-All-Around Transistors

A Semi-Floating Gate Memory with Tensile Stress for Enhanced Performance