Abstract:Titanium dioxide films were deposited on silicon substrates from oxygen/titanium tetraisopropoxide inductively coupled radiofrequency plasmas in a helicon reactor operated at low temperature (<150°C) and low pressure (0.4Pa). The effect of the ion energy (Ei), varied in the 15–175eV range, on the morphology, microstructure and optical properties of the films is investigated. Scanning electron microscopy (SEM) shows that at low energy (Ei=15eV), the film exhibits a columnar morphology consisting of a bottom dense layer, an intermediate gradient layer and a top roughness layer. Increasing the ion energy results in more homogeneous films along the growth direction as confirmed by the in-situ kinetic ellipsometry measurements and post deposition spectroscopic ellipsometry data analysis. In addition, the atomic force microscopy (AFM) measurements reveal that the film top surface becomes smoother as Ei is increased. X-ray diffraction (XRD) diagrams show that only anatase is identified in the film deposited at 15eV, whereas the complete phase transformation from anatase to rutile occurs at Ei=75eV. These results are in good agreement with the Fourier transform infrared spectroscopy (FTIR) spectra which also show that the hydroxyl groups absorbed in the films deposited at 15eV, are greatly decreased for Ei≥45eV. Suitable structural models combined with the Tauc–Lorentz dispersion law have been found to accurately fit the spectroscopic ellipsometry experimental data. The results in good agreement with SEM and AFM measurements are also consistent with the structural properties evidenced by XRD and FTIR. The refractive index (n) can be increased significantly by increasing the ion energy from 15eV to 75eV, reaching a value of 2.49 at 1.96eV. Upon increasing the ion energy above 75eV n is shown to decrease due to micropores which are formed in the films.

Structure and Optical Properties of TiO2 Thin Film Deposited by Ion Beam Assistant Reactive Electron Beam Evaporation

APPLICATION AND OPTICAL PROPERTIES OF TiO_2 THINFILMS PREPARED BY CHEMICAL VAPOUR DEPOSITION

Electrochromism of titanium oxide thin films

Controllable Hydrothermal Synthesis, Optical and Photocatalytic Properties of TiO2 Nanostructures

Crystallization Behaviors of TiO2 Films Derived from Thermal Oxidation of Evaporated and Sputtered Titanium Films

Investigation of microstructure evolution in Pt-doped TiO2 thin films deposited by rf magnetron sputtering

Study of the Crystal Structure, Band Gap and Dispersion Evolution in Titanium Oxide Thin Films

Study on Structural, Optical and Hydrophilic Properties of FTO/TiO2 Tandem Thin Film Prepared by Aerosol-Assisted Chemical Vapor Deposition Method

Study of optical and electrical properties of TiN thin films prepared by cathodic ion sputtering

Optical Properties of Thin Oxide Films Produced by Energetic Ion Beams

Structural and Optical Properties of RF-biased PECVD TiO2 Thin Films Deposited in an O2/TTIP Helicon Reactor

Thickness Dependent Optical Properties of Titanium Oxide Thin Films

Contribution of thickness dependent void fraction and TiSi xOy interlayer to the optical properties of amorphous TiO2 thin films

Structure and optical properties of TiO2 thin films deposited by ALD method

TiO2 films prepared by DC reactive magnetron sputtering at room temperature: Phase control and photocatalytic properties

Effect of ion bombardment on the structural and optical properties of TiO 2 thin films deposited from oxygen/titanium tetraisopropoxide inductively coupled plasma

The Structure and Properties of V Doped TiN Films Prepared at Various Temperatures

Intrinsic Properties of Multi-Layer TiO2/V2O5/TiO2 Coatings Prepared via E-Beam Evaporation

Temperature-dependent optical properties of titanium oxide thin films studied by spectroscopic ellipsometry

Preparation and Properties of Titanium Oxide Thin Film by Midfrequency Alternative Reactive Magnetron Sputtering Technique

Optical Constants and Band Gap Evolution with Phase Transition in Sub-20-nm-Thick TiO2 Films Prepared by ALD