Abstract:This study focuses on reducing NOx x emissions in large-scale municipal solid waste (MSW) grate furnaces through in-bed combustion control. A multi-section fuel bed model with thermally thick treatment is developed to accommodate the configurations of large-scale MSW grate furnaces. The model incorporates detailed sub-grid models to simulate the intraparticle gradient, and the stochastic mixing is accounted to deal with the multi- section fuel beds with vertical drop-offs. The influences of primary air distribution and average grate velocity on combustion status and NOx x emissions are investigated numerically and validated in a 600 t/d MSW grate boiler. The results indicate that combining a relatively low primary air ratio with a thickened fuel bed ensures both reduced NOx x emissions and high burnout efficiency. By reducing the excess air ratio of primary air from 1.2 to 0.9 and distributing it through a rear-enhanced air mode, the overall NOx x emission decreased from 398.50 mg/ Nm3 3 to 215.05 mg/Nm3, 3 , although at the expense of an increased unburned carbon content from 1.995 wt% to 3.063 wt%. Further lowering the grate velocity to thicken the fuel bed allowed for leveraging the heterogeneous reduction effect of the char layer, reducing the NOx x emissions to 184.95 mg/Nm3. 3 . Additionally, the unburned carbon content was also remarkably reduced to 1.560 wt%. The proposed strategies of delaying the primary air supply and thickening the fuel bed offer a cost-effective alternative to post-combustion measures, with which the MSW grate boilers can achieve lower NOx x emissions while maintaining efficient and stable combustion.

SIMULATION STUDY ON SNCR FOR NOx REMOVAL FROM CHAIN-GRATE FURNACE

Numerical Study of SNCR Process in Coal-Fired Boiler with Large Capacity

Full-Scale Numerical Investigation of a Selective Noncatalytic Reduction (SNCR) System in a 100 MW Utility Boiler with Complex Chemistry and Decoupling Approach

Numerical Simulation of Nitrogen Oxide Emission Characteristics of A Retrofitted Chain Grate Boiler

The simulative optimization of atomization diameter and spray flux of reductant based on fume parameters in selective non-catalytic reduction (SNCR)process

Numerical Study of SNCR Process in Large Coal Fired Utility Boiler

Numerical Study of Selective Non-Catalytic Reduction Process in Large Utility Boiler

Numerical Simulation of Furnace Process in a 600 MW Ultra Supercritical Boiler Utilizing Selective Noncatalytic Reduction Technology

Numerical simulation and engineering confirmation of hybird SNCR/SCR process in commercial coal-fired boiler

Numerical simulation of SNCR in a 300 MW pulverized-coal boiler

A Numerical Investigation of NOx Concentration at the Outlet of a Coal-Fired Chain Grate Boiler

MODELING AND EXPERIMENTAL STUDY ON NO_x REDUCTION IN FURNACE WITH AMMONIA INJECTION

Numerical study of mixing characteristic between flue and droplet at 410t/h coal-fired boiler SNCR system

Simulation of Selective Non-catalytic Reduction Process by the Model of Laminar Finite Rate with FLUNT

Numerical Analysis of NOx Reduction in Large-Scale MSW Grate Furnace Through In-Bed Combustion Optimization Using Multi-Section Fuel Bed Model with Thermally Thick Treatment

Experimental and Modeling Study on the Mechanism and Sensitive Parameters of the Thermal DeNOx Process

Computational Fluid Dynamics Simulation of Combustion and Selective Non-Catalytic Reduction in a 750 T/d Waste Incinerator

Numerical Investigation on Promoting Selective Non-catalytic Reduction with Methane Additive by Computational Fluid Dynamics

Numerical Simulation and Optimization of SNCR System for CFB Boilers

Numerical Simulation of Selective Non-catalytic Reduction Process with Turbulence Mixting Influence

Numerical Study Of Furnace Process Of A 600 Mw Pulverized Coal Boiler Under Low Load With Sncr Application