Abstract:Ammonia (NH 3 ) cofiring is a promising approach to reduce the CO 2 emissions from coal-fired power plants. However, the potential drastic increase of NO x emissions may inhibit the wide implementation of NH 3 cofiring. To explore the potential NO x control strategies, the effects of NH 3 cofiring ratio ( RNH3 ), NH 3 injection mode and overfire air (OFA) rates on the NO x emission characteristics of NH 3 /coal cofiring are studied in a test furnace that allow for flexible control of the injection positions and combustion environment of NH 3 . The results show that when NH 3 is injected with coal stream (top mixing mode), the NO x emissions increase and then decrease with the increase of RNH3 under all OFA rates. However, when NH 3 is fed through the side port of furnace separately (side mixing mode), the NO x emissions exhibit distinct trends under different OFA rates. Under lower OFA rates, the NO x emissions show monotonical decrease with the increase of RNH3 , while under higher OFA rates the NO x emissions first decrease and then increase with the increase of RNH3 . Consequently, higher OFA rates could produce higher NO x emissions than lower OFA rates. This indicates that air-staging is not always effective in the NO x reduction of NH 3 cofiring. Thus, although the side mixing mode of NH 3 cofiring exhibits overall better performance in NO x control, caution is needed to accommodate the OFA rate with NH 3 cofiring ratio. Although a variety of trends of NO x emissions were observed in this study, the results demonstrate that all these trends are in fact governed by the same mechanism – the competition between the NO-formation and NO-reduction reactions of NH 3 in the varying O 2 environment in the furnace. By creating appropriate O 2 environment in the furnace, the NO x emissions of NH 3 /coal cofiring could be substantially lower than that of pure coal combustion. The findings of these paper are instrumental in the design and operation of NH 3 cofiring system in full scale coal-fired boilers to achieve effective NO x control.

MODELING AND EXPERIMENTAL STUDY ON NO_x REDUCTION IN FURNACE WITH AMMONIA INJECTION

Experimental and Modeling Study on the Mechanism and Sensitive Parameters of the Thermal DeNOx Process

D309 LOW NOX EMISSION WITH AMMONIA INJECTION DURING COAL COMBUSTION

Experimental Study and Mechanism Analysis on Selective Non-Catalytic Reduction Reactions

NOx Reduction by Aqua Ammonia Injection at 2.11 MW Tangential Pulverized Fired Boiler

Experimental and Modeling Study of the Effect of CH(4) and Pulverized Coal on Selective Non-Catalytic Reduction Process.

Numerical Study of SNCR Process in Coal-Fired Boiler with Large Capacity

Experiment and Mechanism Investigation on Advanced Reburning for NO(x) Reduction: Influence of CO and Temperature.

Experimental and Kinetic Modeling Investigation of NOx Control in Coal Combustion by Ammonia Reburning

Experimental Study on NOx Reduction by Nitrogen Agents and Pyrolysis Characteristic of Nitrogen Agents

Experimental study and kinetic analysis of NO emission characteristics in ammonia/coal co-firing process with different ammonia injection methods

Experimental and kinetic modeling investigation of NO x control in coal combustion by ammonia reburning

Experimental Research on SNCR Applied in Power Plant Boiler: Impact of Temperature and Urea Solution Injection Volume Flow Rate

Full-Scale Numerical Investigation of a Selective Noncatalytic Reduction (SNCR) System in a 100 MW Utility Boiler with Complex Chemistry and Decoupling Approach

Analysis of ammonia combustion for decarbonization followed by selective non-catalytic reduction of nitrogen oxides

Experimental study on the effects of ammonia cofiring ratio and injection mode on the NO x emission characteristics of ammonia-coal cofiring

Experimental and Modeling Study on the Influence of H2 Addition on Selective Non-catalytic Reduction Process

An experimental and theoretical study of NO heterogeneous reduction in the reduction zone of ammonia co-firing in a coal-fired boiler: Influence of CO

Experimental and Mechanism Study on NO Formation Characteristics and N Chemical Reaction Mechanism in Ammonia-Coal Co-Firing

Effect of Methane and Temperature on NO Removal Using by the Selective Non-Catalytic Reduction

SIMULATION STUDY ON SNCR FOR NOx REMOVAL FROM CHAIN-GRATE FURNACE