Abstract:The environmental problem concerning Hg pollution has received worldwide attention. Coal fired power plants are responsible for large amounts of Hg emission and produce abundant by-products in particular gypsum which is capable of extensive use. In this study, the migration of Hg in the gypsum production process and effluent treatment process in a typical wet flue gas desulfurization (WFGD) system was investigated and the temperature programmed decomposition technique was applied to identified Hg species in these products. Hg concentration in both the solid and liquid fraction of samples obtained in wet flue gas desulfurization system were determined by atomic fluorescence spectroscopy. The results indicated that gypsum accounted for a small proportion (29.9%) of Hg while the majority of Hg was transported to effluent treatment process where over 99.6% Hg was removed. The amount of Hg discharged from WFGD in the drainage, gypsum, and desulfurization sludge were 0.04 t/yr, 13.56 t/yr, and 9.56 t/yr, respectively. Desulfurization environment promoted HgS formation and lead to HgS being dominant in gypsum. The alkaline environment in the effluent treatment process contributed to the formation of HgO which was regarded as the primary Hg compound and accounted for 49.5%, 54.8%, and 78.5% of the total Hg in the neutralization tank, precipitation tank, and flocculation tank, respectively. The occurrence of HgCl2 in the solid fraction attributed to absorption of solid particles when it precipitated and was enhanced by the addition of chemicals. There was no obvious difference in the proportion of HgSO4 in the effluent treatment process. Systematic studies on difference in the partitioning of Hg species enables a better understanding on Hg behavior and provides conferences on targeting removal of Hg species in WFGD system.

Analysis of Scaling on Gas-Gas Heater Surfaces of Wet Flue Gas Desulfurization Systems

Analysis of Scaling on Absorber Wall of CFB-FGD System and Its Mechanism

Analysis of Blocking Reason on Gas-gas Heater of Dingzhou Power Plant's Flue Gas Desulfurization System

Mechanism of Dry Fgd Process and Characters of Circulating Particles

Application and Research of High Molecular Carboxylates in Desulphurization System of Thermal Power Plant

Analysis and Optimization of Chemical Processing Parameters for Wet Flue Gas Desulphurization System

Origin and solution of the“gypsum rain”problem of limestone-gypsum WFGD system

Study on characteristics of organic components in condensable particulate matter before and after wet flue gas desulfurization system of coal-fired power plants

Experimental Study on Emission Characteristics of Particulate Matters from Wet Flue Gas Desulfurization System of a Coal-fired Power Plant

Holographic Slurry Droplet Monitor: Design and Its Application to 1000 MW Coal-Fired Power Unit

Experimental Study on Removal Effect of Wet Flue Gas Desulfurization System on Fine Particles from a Coal-fired Power Plant

Trace Element Distribution During Wet Flue Gas Desulphurization System

ANALYSIS AND CALCULATION OF THE LIQUID PHASE SYSTEM IN LIMESTONE/GYPSUM WET FLUE GAS DESULFURATION PROCESS

Measurement of Slurry Droplets in Coal-Fired Flue Gas after Wfgd

Modeling on circulating fluidized bed flue gas desulfurization

Study on the distributed pore characteristic of dry flue gas desulfurization

Experimental research on properties of inhalable particulate matters affceted by wet flue gas dedulfurization system

Formation and migration of soluble ions in condensable particulate matter in limestone-gypsum wet flue gas desulfurization system

Operating experience of CFB semi-dry FGD with novel humidification technology in China

Migration and identification of mercury species in wet flue gas desulfurization system using temperature programmed decomposition

On-the-spot Test of the Slagging in a Grate-circulating Bed Garbage Incinerator Superheater