Experiment and Analysis on Radiation Properties of SiO2/Ag Optical Solar Reflector Coating

C. Sun,H. F. Sun,Z. Y. Wang,X. L. Xia

DOI: https://doi.org/10.1016/j.ast.2018.09.015

IF: 5.457

2018-01-01

Aerospace Science and Technology

Abstract:The Thermal Control Coatings (TCC) on the surfaces of lunar rover/landers plays an important role for radiation heat transfer to allow the detectors survive the extremely critical thermal environment on the moon. Optical Solar Reflector (OSR) coating is usually considered as a good candidate TCC due to its excellent radiation properties such as low solar absorptance and high infrared emittance. In this study, SiO2/Ag coating, commonly used as OSR, was investigated to study its radiation properties, combining experiment measurement with numerical simulations. Based on the self-made setup with the comparison method, the temperature dependence of the normal infrared emittance of the OSR coating was obtained, covering the temperature range from 326 K to 404 K, to simulate the temperature condition on the Moon in the daytime. The direction hemisphere spectral reflectance at the typical wavelength of 0.6328 μm, 1.34 μm and 3.39 μm was also investigated in details. It was found that the spectral reflectance of the OSR coating at visible wavelengths is much higher than that at infrared wavelengths. In addition, numerical simulation result showed good agreement with the experimental data, and the relative error is 4.49% at 0.6328 μm.