Abstract:Despite widespread industrial importance, predicting metal solubilities in highly concentrated, multicomponent aqueous solutions is difficult due to poorly understood ion-ion and ion-solvent interactions. Aluminum hydroxide solid phase solubility in concentrated sodium hydroxide (NaOH) solutions is one such case, with major implications for ore refining, as well as processing of radioactive waste stored at U.S. Department of Energy legacy sites, such as the Hanford Site, Washington State. The solubility of gibbsite (α-Al(OH)3) is often not well predicted because other ions affect the activity of hydroxide (OH-) and aluminate (Al(OH)4-) anions. In the present study, we systematically examined the influence of key anions, nitrite (NO2-) and nitrate (NO3-), as sodium salts on the solubility of α-Al(OH)3 in NaOH solutions taking care to establish equilibrium from both under- and oversaturation. Rapid equilibration was enabled by use of a highly pure and crystalline synthetic nano-gibbsite of well-defined particle size and shape. Measured dissolved aluminum concentrations were compared with those predicted by an α-Al(OH)3 solubility model derived for simple Al(OH)4-/OH- systems. Specific anion effects were expressed as an enhancement factor (Alenhc) conveying the excess of dissolved aluminum. At 45 °C, NaNO2 and NaNO3-containing systems exhibited Alenhc values of 2.70 and 1.88, respectively, indicating significant enhancement. The solutions were examined by Raman and high-field 27Al NMR spectroscopy, indicating specific interactions including Al(OH)4--Na+ contact ion pairing and Al(OH)4--NO2-/NO3- ion-ion interactions. Dynamic evolution of the α-Al(OH)3 particles including growth and agglomeration was observed revealing the importance of dissolution/reprecipitation in establishing equilibrium. These studies indicate that incomplete ion hydration, as a result of the low water activity in these concentrated electrolytes, results in: (i) enhanced reactivity of the hydroxide ion with respect to α-Al(OH)3; (ii) increased concentrations of Al(OH)4- in solution; and (iii) stronger ion-ion interactions that act to stabilize the supersaturated solutions. This information on the mechanisms by which α-Al(OH)3 becomes supersaturated is essential for more energy-efficient aluminum processing technologies, including the treatment of millions of gallons of Al(OH)4--rich high-level radioactive waste.

Increasing Precipitation Rate from Sodium Aluminate Solution by Adding Active Seed and Ammonia

A Kind Of Activity Seed Used For The Precipitation Of The Sodium-Aluminate Liquor

Preparation of Near-Spherical α-Al2O3 Particles by Enhanced Precipitation of Gibbsite from Sodium Aluminate Solution Using Highly Dispersed Al2O3 as Seeds

Effects of Methanol on the Seeded Precipitation of Al(OH)3 from Potassium Aluminate Solution

Effect of Polyamidoamine on Surface Tension and Seed Precipitation in Sodium Aluminate Solution

Synthesis of Nano-Alumina Hydroxide Sol Using Sol-gel Method

Preparation of Near-Spherical α-Al 2 O 3 Particles by Enhanced Precipitation of Gibbsite from Sodium Aluminate Solution Using Highly Dispersed Al 2 O 3 as Seeds

An Experimental Study of Extracting Aluminum Hydroxide from High Caustic Sodium Aluminate Solution

Effect of impurity ions on the primary nucleation of ammonium alum precipitated from aqueous solution

Gas-Liquid Interfacial Deposition Synthesis of Alumina with Large Mesopores

Preparation and characterisation of seed for simultaneous removal of sulphur and iron from sodium aluminate solution

Synthesis of nano α-alumina powders using hydrothermal and precipitation routes: a comparative study

Secondary Nucleation Of Aluminium Trihydroxide In Bayer Sodium Aluminate Solution

Preparation of Pseudoboehmite with Large Pore Volume and High Specific Surface Area from Sodium Aluminate Solution by Hydrothermal Precipitation Using SB Powder as the Seed

A New Homogeneous Precipitation Route to Ammonium Aluminum Carbonate Hydroxide

Desulfurization by Adding Sodium Nitrate in the Production of Alumina from High-Sulfur Bauxite

Effect Of Potassium Sodium Tartrate And Sodium Citrate On The Preparation Of Alpha-Calcium Sulfate Hemihydrate From Flue Gas Desulfurization Gypsum In A Concentrated Electrolyte Solution

A single-step crystallization process to remove potassium from sodium aluminate solution

Ion-ion interactions enhance aluminum solubility in alkaline suspensions of nano-gibbsite (α-Al(OH)3) with sodium nitrite/nitrate

Effect of Ammonium Chloride on Leaching Behavior of Alkaline Anion and Sodium Ion in Bauxite Residue

h of preparation of fi ne active alumina with high speci fi c surface area from sodium aluminate solution