Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

Comparison of Corrosion Mechanism of Low-Alloy Pipeline Steel Used for Flexible Pipes at Vapor-Saturated CO2 and CO2 -Saturated Brine Conditions

Corrosion Behavior of Low‐alloy Steel Used for Pipeline at Vapor‐saturated CO2 and CO2‐saturated Brine Conditions

Corrosion Mechanism of Low‐alloy Steel Used for Flexible Pipe in Vapor‐saturated H2S/CO2 and H2S/CO2‐saturated Brine Conditions

Comparison of Corrosion Behaviour of Low-Alloy Pipeline Steel Exposed to H2S/CO2-saturated Brine and Vapour-Saturated H2S/CO2 Environments

Comparison of Corrosion Behaviors of Low-Alloy Steel Exposed to Vapor-Saturated H2s/Co2 and H2s/Co2-Saturated Brine Environments

Corrosion Behavior of Low-Alloy Steel with Martensite/Ferrite Microstructure at Vapor-Saturated Co2 and Co2-Saturated Brine Conditions

Corrosion Behavior of Low-Alloy Pipeline Steel Exposed to H2S/CO2-Saturated Saline Solution

Corrosion Behavior of Low Alloy Pipeline Steel in Saline Solution Saturated with Supercritical Carbon Dioxide

Corrosion Behavior of Low-Alloy Pipeline Steel with 1% Cr under CO 2 Condition

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Corrosion Behaviour of Low-Alloy Martensite Steel Exposed to Vapour-Saturated CO2 and CO2-saturated Brine Conditions

Discussion of the CO 2 corrosion mechanism between low partial pressure and supercritical condition

Research on the Corrosion Behavior of Q235 Pipeline Steel in an Atmospheric Environment through Experiment

Corrosion Behavior of Pipeline Steel Welds in Simulated Produced Water with Different Co2 Partial Pressures under High Temperature

Study on corrosion properties of pipelines in simulated produced water saturated with supercritical CO2

A Comparative Analysis of the Effects of CO2 Corrosion on Banded Pipeline Steel Structure in Lower Temperature Areas

Investigation of Supercritical CO2 Corrosion Behavior of X80 Carbon Steel in Pipelines: an in Situ Experimental and DFT Study

Corrosion of Cr bearing low alloy pipeline steel in CO2 environment at static and flowing conditions

Corrosion Behavior of X65 Steel in CO2-saturated Oil/water Environment of Gathering and Transportation Pipeline

Corrosion Behavior of High-Strength Steel for Flexible Riser Exposed to CO 2 -Saturated Saline Solution and CO 2 -Saturated Vapor Environments

Failure analysis of CO2 corrosion of natural gas pipeline under flowing conditions