Abstract:A combined steady-state and transient approach is employed to investigate the corrosion behavior of X80 pipeline steel in carbon dioxide-saturated brines. Continuous bubbling of carbon dioxide into a test vessel with 1 liter capacity is performed to simulate the flowing condition. The measurement of time-dependent open-circuit potential, polarization resistance, and electrochemical impedance spectroscopy (EIS) is conducted to interpret the evolution of dissolution processes at the corroding interface. Three distinguishing stages are observed at a temperature of 60 °C during a whole exposure of 144 h. Analyses mainly based on the consecutive mechanism show that after the first stage of the active-adsorption state, the anodic reaction is significantly retarded by the accumulation of (FeOH)ads on the iron surface, causing a sharp increase in the polarization resistance and the open-circuit potential, as well as the disappearance of the inductive loop in EIS. At the third stage, the formation of the corrosion product layer similarly reduces both the anodic and cathodic reactions, which arouses a linear increase in the polarization resistance with time and a capacitive loop in EIS but changes the open-circuit potential slightly. An increase in salinity in this study reduces the polarization resistance and enhances iron dissolution by promoting the formation and relaxation of (FeOH)ads; however, it brings little change to the developing time of the three stages obviously. At a low temperature of 20 °C, a protective product layer is not observed in carbon dioxide-saturated brine, and the dissolution of iron is mainly under activation control during the whole exposure. A notable enlarged polarization resistance and different interfacial processes are observed in an alkaline solution compared with those in acidic environments, which is deduced to be resulted from an impedance in the relaxation of (FeOH)ads by increasing pH. The observations in this study support well that the iron dissolution reaction at the initial stage exposed in carbon dioxide aqueous environments is dominant by water adsorption on the iron surface, and further investigation should be performed on the role that carbon dioxide plays in the evolution of corrosion products and the formation of a protective film on the steel surface by taking into account local water chemistry.

A Comparative Analysis of the Effects of CO2 Corrosion on Banded Pipeline Steel Structure in Lower Temperature Areas

Corrosion Behavior of Low‐alloy Steel Used for Pipeline at Vapor‐saturated CO2 and CO2‐saturated Brine Conditions

CO 2 corrosion behavoir of X70 pipeline steel

Corrosion Behavior of X90 Pipeline Steel in CO2 Environment Evaluated by Orthogonal Test

Comparison of Corrosion Mechanism of Low-Alloy Pipeline Steel Used for Flexible Pipes at Vapor-Saturated CO2 and CO2 -Saturated Brine Conditions

Relationship between microstructure and corrosion behavior of high-grade pipeline steel in a low-temperature environment

Effect Of Temperature On Corrosion Behaviour Of X70 Steel In High Pressure Co2/So2/O-2/H2o Environments

Corrosion Behavior of Pipeline Steel in NACE High Pressure Carbon Dioxide Solutions with Saturated Hydrogen Sulfide

Effect of CO_2 Partial Pressure on Corrosion Resistance of X80 Pipeline Steel

Corrosion Behavior of Low-Alloy Pipeline Steel with 1% Cr under CO 2 Condition

Corrosion Investigation of Commercially Available Linepipe Steel in CO2 Environment

Corrosion Behavior of Pipeline Steel Welds in Simulated Produced Water with Different Co2 Partial Pressures under High Temperature

Corrosion Behaviors of Gas-oil Transporting Pipelines in Carbon Dioxide Solution

Influence Of Microstructure On Mechanical Properties And Corrosion Behavior Of 3%Cr Steel In Co2 Environment

INFLUENCE OF TEMPERATURE,CO_2 PARTIAL PRESSURE, FLOW RATE AND pH VALUE ON UNIFORM CORROSION RATE OF X65 PIPELINE STEEL

Effect of CO2 partial pressure on the corrosion in flow and transport lines under the erosion action:A case study from the Xushen-6 Gas Station in the Daqing Oil Field

Effect of Main Controlling Factor on the Corrosion Behaviour of API X65 Pipeline Steel in the CO2/oil/water Environment

Corrosion Behavior of Low Alloy Pipeline Steel in Saline Solution Saturated with Supercritical Carbon Dioxide

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

Mechanical Properties and CO2 Corrosion Behavior of High Strength and Toughness X80 Pipeline Steel

Discussion of the CO 2 corrosion mechanism between low partial pressure and supercritical condition