Abstract:Results are presented for modelling of the evaporation and magnetron sputter deposition of Zn(x)O(y) onto an O-terminated ZnO (0001¯) wurtzite surface. Growth was simulated through a combination of molecular dynamics (MD) and an on-the-fly kinetic Monte Carlo (otf-KMC) method, which finds diffusion pathways and barriers without prior knowledge of transitions. We examine the effects of varying experimental parameters, such as substrate bias, distribution of the deposition species and annealing temperature. It was found when comparing evaporation and sputtering growth that the latter process results in a denser and more crystalline structure, due to the higher deposition energy of the arriving species. The evaporation growth also exhibits more stacking faults than the sputtered growth. Post-annealing at 770 K did not allow complete recrystallization, resulting in films which still had stacking faults where monolayers formed in the zinc blende phase, whereas annealing at 920 K enabled the complete recrystallization of some films to the wurtzite structure. At the latter temperature atoms could also sometimes be locked in the zinc blende phase after annealing. When full recrystallization did not take place, both wurtzite and zinc blende phases were seen in the same layer, resulting in a phase boundary. Investigation of the various distributions of deposition species showed that, during evaporation, the best quality film resulted from a stoichiometric distribution where only ZnO clusters were deposited. During sputtering, however, the best quality film resulted from a slightly O rich distribution. Two stoichiometric distributions, one involving mainly ZnO clusters and the other involving mainly single species, showed that the distribution of deposition species makes a huge impact on the grown film. The deposition of predominantly single species causes many more O atoms at the surface to be sputtered or reflected, resulting in an O deficiency of up to 18% in the deposited film and therefore resulting in more stacking faults and phase boundaries. The methods used allow analysis of key mechanisms that occur during the growth process and give hints as to the optimum conditions under which complete crystalline layers can form.

Phase Diagram of Interfacial Growth Modes by Vapor Deposition and Its Application for ZnO Nanostructures

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Publisher's Note: Phase Diagram of Interfacial Growth Modes by Vapor Deposition and Its Application for ZnO Nanostructures [phys. Rev. B 96 , 115411 (2017)]

Vapor phase growth and photoluminescence of oriented-attachment Zn2GeO4 nanorods array

Competitive Adsorption and Two-Site Occupation Effects in Metal-Organic Chemical Vapor Deposition of Zno

Modelling the growth of ZnO thin films by PVD methods and the effects of post-annealing

Modeling Analysis of the Mocvd Growth of Zno Film

Influence of Oxygen Partial Pressure on the Adsorption and Diffusion During Oxide Growth: Zno(0001) Surface

Eutectic Condensation and Nucleation in Vapor-Liquid-Solid Grown Zno Nanorod Arrays on Si Substrate

Evolution of Zinc Oxide Nanostructures Through Kinetics Control.

Regrowth of template ZnO nanowires for the underlying catalyst-free growth mechanism

Phase Diagram of growth modes in Graphene Growth on Cooper by Vapor Deposition

Pinpoint Growth Mechanism of ZnO Nanoprisms

Numerical and Experimental Comparative Study of Metal-Organic Chemical Vapor Deposition of ZnO

Crystal plane-orientation dependent phase evolution from precursor to porous intermediate phase in the vapor phase dealloying of a Co-Zn alloy

A First-Principles Study Of Zno Polar Surface Growth: Adsorption Of Znxoy Clusters

Simulation of the Mocvd Reactor for Zno Growth

Nucleation Kinetics and Structure Evolution of Quasi-Two-Dimensional ZnO at the Air-Water Interface: An In Situ Time-Resolved Grazing Incidence X-ray Scattering Study

Formation of Zinc Oxide Micro-Disks Via Layer-By-Layer Growth and Growth Mechanism of Zno Nanostructures

Zinc Oxide Nanostructures: Morphology Derivation and Evolution

Monotectic growth evolution and raman scattering of self-assembled ZnO hierarchical micro-nanostructures