Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Experimental Study on Condensation of High-Pressure Steam in A Horizontal Tube with Pool Boiling Outside

Experimental Investigation on Steam Condensation Local Heat Transfer Characteristics Inside Horizontal Tube

Forced Condensation Heat Transfer Characteristics of Vapour in the Presence of Noncondensable Gas in Horizontal Tubes Operating at High Pressures

Experimental Research on Condensation Heat Transfer Characteristics of Low Mass Flow Rate Steam in a Horizontal Tube

The Temperature Distribution Characteristics of Slightly Inclined Tube With High Pressure Steam In-Tube Condensation

Influence of Operating Conditions on In-Tube Vapour Condensation Heat Transfer Characteristics in the Presence of Noncondensable Gases at High Pressure

Experimental investigation on flow condensation pressure drop of steam in a horizontal tube

Experimental Study on the Condensation of Steam with Air out of the Vertical Tube Bundles

Condensation Heat Transfer of Steam on Vertical Micro-Tubes

Theoretical and Experimental Analyses of Two-Phase Flow Condensation Heat Transfer Inside the Horizontal Micro-Fin Tube

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Experimental study on direct contact condensation of stable steam jet in water flow in a vertical pipe

Local heat transfer characteristics of saturated steam forced convection condensation inside horizontal tube

ICONE23-1089 EXPERIMENTAL STUDY ON LOCAL FORCED CONVECTION CONDENSATION HEAT TRANSFER CHARACTERISTICS OF STEAM/AIR MIXTURES IN A HORIZONTAL TUBE

Investigation on Heat Transfer of In-Tube Supercritical Water Cooling Accompanying Out-Tube Pool Boiling

Experimental and theoretical investigation on condensation inside a horizontal tube with noncondensable gas

Heat Transfer Characteristics of Steam Condensation Flow in Vacuum Horizontal Tube

Numerical Analysis of Heat Transfer Enhancement on Steam Condensation in the Presence of Air Outside the Tube

Experimental Study on Single- to Two-Phase Flow and Heat Transfer of Water in a Small Tube

An Investigation on Heat Transfer Characteristics of Different Pressure Steam-Water in Vertical Upward Tube