Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Experimental study of the effect of non-condensable gases on steam condensation over a vertical tube external surface

Influence of Operating Conditions on In-Tube Vapour Condensation Heat Transfer Characteristics in the Presence of Noncondensable Gases at High Pressure

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Forced Condensation Heat Transfer Characteristics of Vapour in the Presence of Noncondensable Gas in Horizontal Tubes Operating at High Pressures

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Experimental Study of Condensation Heat Transfer of Steam in the Presence of Non-Condensable Gas CO2 on a Horizontal Tube at Sub-Atmospheric Pressure

A condensation heat transfer model with light gas effects in non-condensable gas mixtures

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Direct Contact Condensation Heat Transfer Characteristics of Vapor with Noncondensable Gases in Horizontal Tubes

Experimental Investigation of Condensation Heat Transfer of Non-condensable Gas Containing Steam on 3-Dimensionally Finned Tubes, Horizontally Positioned

Experimental Study on the Effect of Non-Condensable Gas Dissolved in Sub-Cooled Water on Steam Jet Condensation in a Rectangular Channel

The Investigation on Heat Transfer Characteristics of Steam Condensation in Presence of Noncondensable Gas under Natural Convection

Experimental and theoretical investigation on condensation inside a horizontal tube with noncondensable gas

Effect of Non-Condensable Gases on Steam Condensation in a Vertical Pipe with Forced Convection

Experimental Research on Heat Transfer and Flow Resistance of In-Tube Condensation of Humid Air

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental Study on Steam Condensation with Non-Condensable Gas in Horizontal Microchannels

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Effect of Non-Condensation Gas on Heat Transfer of Direct Contact Condensation

Experimental Study on Condensation of High-Pressure Steam in A Horizontal Tube with Pool Boiling Outside