Abstract:The carbon dioxide (CO2) trans-critical cycle is widely used in refrigerating systems, air conditioning, and heat pumps. Heat transfer behaviors at subcritical and supercritical pressures play essential roles in trans-critical thermohydraulic systems. In past decades, boiling heat transfer at subcritical pressure and 'single-phase' convective heat transfer at supercritical pressure have been broadly discussed; however, evaluation of the heat transfer difference of CO2 between supercritical and subcritical pressures remains lacking. In this study, experimental investigations are conducted to explore the heat transfer characteristics of the vertical flow of CO2 in a wide pressure range (6.2 MPa-8.0 MPa) within a circular tube (inner diameter = 5 mm). The range of operating conditions includes a mass flux (G) between 0 and 190 kg/m(2) s and a heat flux (q) of up to 105 kW/m(2). Parametric effects (e.g., heat flux, inlet temperature, and mass flux) within these experimental conditions are also analyzed. Measurement results show that the inner-wall temperature at subcritical pressure is higher than that at supercritical pressure when a boiling crisis occurs. Closer to the critical pressure, a boiling crisis occurs more easily at lower heat fluxes, but the corresponding temperature peak declines. Higher temperatures are measured farther from critical pressure, indicating that overheating induced by boiling heat transfer at subcritical pressure is far more significant than that governed by the deterioration of convective heat transfer at supercritical pressure. Additionally, a qualitative analysis of physical mechanisms governing observed heat transfer differences is performed, confirming variations in fluid thermophysical properties and a bubble-like flow pattern. (C) 2020 Elsevier Ltd. All rights reserved.

Experimental Study of Condensation Heat Transfer of Steam in the Presence of Non-Condensable Gas CO2 on a Horizontal Tube at Sub-Atmospheric Pressure

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Experimental study of the effect of non-condensable gases on steam condensation over a vertical tube external surface

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Experimental Study Of Boiling Heat Transfer Of Subcritical Co2 In Horizontal Small Diameter Tubes

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

EXPERIMENTAL INVESTIGATION OF CONVECTION HEAT TRANSFER OF CO_2 AT SUPERCRITICAL PRESSURES IN VERTICAL CIRCULAR TUBE

Experimental Comparison of the Heat Transfer of Carbon Dioxide under Subcritical and Supercritical Pressures

Convection Heat Transfer of Co2 at Supercritical Pressures in A Vertical Mini Tube

Experimental and Simulation Investigation on Heat Transfer Characteristics of In-Tube Supercritical CO2 Cooling Flow

EXPERIMENTAL STUDY ON EVAPORATING HEAT TRANSFER OF CO2 IN THIN TUBE

Experimental Investigation of Convection Heat Transfer of CO2 at Super-Critical Pressures in Vertical Mini-Tubes and in Porous Media

Experimental Study on the Effect of Non-Condensable Gas Dissolved in Sub-Cooled Water on Steam Jet Condensation in a Rectangular Channel

Supercooling of Steam Condensation in Natural Gas Fumes

Experimental Research on Steam Condensation in Presence of Non-Condensable Gas under High Pressure

Experimental and theoretical investigation on condensation inside a horizontal tube with noncondensable gas

Experimental Study on Condensation of High-Pressure Steam in A Horizontal Tube with Pool Boiling Outside

Research on Heat Transfer Characteristics of Steam Condensation with Non-Condensable Gas at Low Steam Mass Flux