Abstract:The experimental and theoretical researches have been carried out to get the flow boiling heat transfer characteristics of carbon dioxide (CO2 or R744) as a refrigerant in horizontal minichannel. Based on infrared thermal imaging tests and experimental studies on heat transfer coefficients, the heat transfer coefficients and dryout characteristics of CO2 are analyzed qualitatively and quantitatively in following conditions: Heat flux: 2 similar to 35 kW m(-2), Mass flux: 50 similar to 1350 kgm(-2) s(-1), saturation temperature: -10 similar to 15 degrees C, mini-channel inner diameter: 1 mmand 2 mm. Primary conclusions can be drawn from the results of the experiments: The increase of heat flux enhances the nucleate boiling heat transfer of the refrigerant inside mini-channel, which leads to the remarkable increase of heat transfer coefficient. But it speeds up the process of dryout. It also has a certain influence on vapor qualities of dryout at both the starting and the ending stage. The effect of mass flux on heat transfer enhancement depends on the dominant heat transfer mode in the tube. With the increase of mass flow rate, the vapor quality at the start of dryout has a decreasing trend. But the heat transfer coefficient increases at the end of dryout process or even after dryout process; the heat transfer coefficient does not vary monotonically with the saturation temperature: when the saturation temperature is high and even close to CO2' s critical temperature, the heat transfer coefficient increases with the increase of saturation temperature; when the saturation temperature is low, the heat transfer coefficient increases with the decrease of saturation temperature. Besides, during the heat transfer process, the dryout vapor quality falls monotonically with the increase of saturation temperature. It is reasonable to conclude that dryout characteristics have significant influence on heat transfer coefficient. Fang correlation that predicts the heat transfer coefficient of CO2 is in good agreement with the experimental data, which has a mean absolute deviation of 15.7%, and predicts 71.98% of the entire database within similar to 20% and 86.84% of the entire database within similar to 30%. (C) 2017 Elsevier Ltd and IIR. All rights reserved.

EXPERIMENTAL STUDY ON EVAPORATING HEAT TRANSFER OF CO2 IN THIN TUBE

A Research on the Dryout Characteristics of CO 2 'S Flow Boiling Heat Transfer Process in Mini-Channels

Experimental Investigation on Evaporation Heat Transfer and Pressure Drop Characteristics of HFC-161 in a Horizontal Smooth Tube

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Characteristics of Heat Transfer for CO2 Flow Boiling at Low Temperature in Mini-Channel

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Characteristics of Heat Transfer for CO2 Flow Boiling in Mini_channel

Experimental Study Of Boiling Heat Transfer Of Subcritical Co2 In Horizontal Small Diameter Tubes

Experimental Research on Heat Transfer Performance of CO2 Tube Bundle Falling Film Evaporator

Evaporation heat transfer of carbon dioxide at low temperature inside a horizontal smooth tube

EXPERIMENTAL INVESTIGATION OF CONVECTION HEAT TRANSFER OF CO_2 AT SUPERCRITICAL PRESSURES IN VERTICAL CIRCULAR TUBE

EXPERIMENTAL STUDY ON HEAT FLUX EFFECT ON EVAPORATION IN TWO DIMPLE-GROOVED TUBES

A new correlation for carbon dioxide boiling heat transfer coefficient outside evaporating tubes

Experimental Investigation on Heat Transfer of Co(2) Solid-Gas Two Phase Flow with Dry Ice Sublimation

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Experimental Investigation of Evaporation Heat Transfer Inside Horizontal Micro-Fin Tubes

Condensation and Evaporation Heat Transfer Characteristics in Horizontal Smooth and Three-Dimensional Enhanced Tubes

Heat Transfer Performance Analysis on the CO2 Two-phase Thermosyphon Loop

Heat transfer of flow boiling carbon dioxide in vertical upward direction

Eexperimental Study On Flow Evaporation Heat Transfer Characteristics Inside Horizontal Three-Dimensional Enhanced Tubes

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures