Abstract:Silicon heterojunction (SHJ) solar cell that combines traditional pure H2 plasma treatments has been frequently reported in the literature. However, this method requires an individual gas blending step between a-Si:H film deposition and post H2 plasma treatment to stabilize the gas environment in the PECVD chamber. Here, we report the introduction of residual SiH4 molecules in H2 plasma to treat SHJ solar cell devices. In contrast to the traditional H2 plasma treatments, it requires no time interval between the a-Si:H film deposition and H2 plasma treatment, i.e., we merely closed the SiH4 inlet after the a-Si:H deposition. In the meantime, all other PECVD parameters were kept unchanged. Taking advantage of the decreasing SiH4 density during the H2 plasma process, a dense silicon layer was grown onto the top layer of the as-deposited a-Si:H film, which inhibited free H atoms effusing out of the low-mass-density a-Si:H network. The better a-Si:H/c-Si interface passivation results in improvements to both the short-circuit current density (Jsc) and open-circuit voltage (Voc) of the SHJ solar cell in comparison to the counterpart cell treated by the traditional pure H2 plasma. For instance, when the n+ a-Si:H window layer is as thin as ~ 1.8nm, the power-conversion efficiency skyrockets from 2.35% treated by the traditional pure H2 plasma to 16.09% treated by the H2 plasma containing residual SiH4 molecules. For a thicker n+ a-Si:H window layer of ~ 4.3nm, the efficiency is also enhanced from 20.66% to 22.74%. This finding paves the way for a more efficient H2 plasma treatment in pursuit of an outstanding SHJ solar cell.

Underdense A-Si:H Film Capped by A Dense Film As the Passivation Layer of A Silicon Heterojunction Solar Cell

Improved Amorphous/crystalline Silicon Interface Passivation for Silicon Heterojunction Solar Cells by Hot-Wire Atomic Hydrogen During Doped A-Si:H Deposition

The microstructure of underdense hydrogenated amorphous silicon and its application to silicon heterojunction solar cells

Optimized N-Type Amorphous Silicon Window Layers Via Hydrogen Dilution For Silicon Heterojunction Solar Cells By Catalytic Chemical Vapor Deposition

Beyond 25% efficient crystalline silicon heterojunction solar cells with hydrogenated amorphous silicon oxide stacked passivation layers for rear emitter

Study of the correlation between hydrogenated amorphous silicon microstructure and crystalline silicon surface passivation in heterojunction solar cells

Role of Hydrogen in Modifying A-Si:H/c-si Interface Passivation and Band Alignment for Rear-Emitter Silicon Heterojunction Solar Cells

Intrinsic layer modification in silicon heterojunctions: Balancing transport and surface passivation

Balance of efficiency and stability of silicon heterojunction solar cells

Thin heterojunction a-Si:H photovoltaic cell design with no doped a-Si:H layers

Improving the performance of high-efficiency silicon heterojunction solar cells through low-temperature deposition of an i-a-Si:H anti-epitaxial buffer layer

Controllable A-Si:H/c-si Interface Passivation by Residual SiH4 Molecules in H-2 Plasma

Importance of Nanocrystallites in A-Si:H Passivation Layer in Improving the Performance of Silicon Heterojunction Solar Cells

Role of the Buffer at the Interface of Intrinsic A-Si:H and P-Type A-Si:H on Amorphous/crystalline Silicon Heterojunction Solar Cells

Ultra-thin LiF Layer As the Electron Collector for A-Si:H Based Photovoltaic Cell

Damp-Heat-Stable, High-Efficiency, Industrial-Size Silicon Heterojunction Solar Cells

25.11% efficiency silicon heterojunction solar cell with low deposition rate intrinsic amorphous silicon buffer layers

Investigation of dual intrinsic a-Si:H films for crystalline silicon surface passivation by spectroscopic ellipsometry: application in silicon heterojunction solar cells

High Efficiency Dopant Free A-Si:H Solar Cell

Significant Improvement of Passivation Performance by Two-Step Preparation of Amorphous Silicon Passivation Layers in Silicon Heterojunction Solar Cells*

Improved passivation effect at the amorphous/crystalline silicon interface due to ultrathin SiOx layers pre-formed in chemical solutions