Abstract:Coal slime, a low-calorific-value fuel, is a by-product during coal washing, which can be disposed in quantity and fully utilized in circulating fluidized bed (CFB) boiler. This research paid attention to the ignition and combustion behaviors of single coal slime particles, which affect the normal combustion, operation stability and burning efficiency in circulating fluidized bed boiler. The ignition and combustion behaviors including ignition mechanism, ignition delay, ignition temperature and combustion process of single coal slime particles in a vertical heating tube furnace in CO2/O-2 atmosphere were researched under different operation condition parameters, for different gas temperatures (T-g =923,1073, and 1173 K), gas flow rates (V= 0-20 L/min), and oxygen mole concentrations (O-2 %=5-80%). Coal slime particle had three ignition mechanisms in CO2/O-2 atmosphere, namely, homogeneous ignition of volatiles at the windward and leeside of particle, heterogeneous ignition of char and heterogeneous ignition of coal. Only heterogeneous ignition of char and homogeneous ignition of volatiles at the windward of particle occurred in quiescent atmosphere. However, homogeneous ignition region decreased while heterogeneous ignition region increased gradually with the increasing flow rates in the oxygen concentration-gas temperature plane. Different ignition mechanisms were accompanied with various combustion processes. The combustion processes corresponding to heterogeneous ignition of char changed from nameless combustion to flaming combustion as oxygen concentration increased. Moreover, the critical oxygen concentration elevated from 30% to 50% with the increasing flow rate. The ignition temperatures and ignition delays decreased with the increasing gas temperature and oxygen concentration. As the flow rate increased, the trends became more obvious in medium-to-low oxygen concentrations. Compared with the ignition characteristics and combustion processes of coal slime particles in N-2/O-2 atmosphere, those in CO2/O-2 atmosphere were suppressed due to the higher mole heat capacity and lower diffusion rate of oxygen molecule in CO2. (C) 2018 The Combustion Institute. Published by Elsevier Inc. All rights reserved.

Model of coal slime combustion behavior in CFB boiler

Ignition and Combustion Behaviors of Single Coal Slime Particles in CO2/O2 Atmosphere

Experimental Research on Morphology and Drying Characteristics of Coal Slime Dough Injected into Circulating Fluidized Bed Boiler

Investigation on self-sustained combustion, NOx emissions, and ash characteristics of coal slime in a lab-scale fluidized bed

Investigation on Self-Sustained Combustion and Its Ash Properties of Coal Slime in Different Scale Fluidized Beds—part II: 12t/h Fluidized Bed Boiler of Coal Slime

Computations of A Circulating Fluidized-Bed Boiler with Wide Particle Size Distributions

Simulation of Combustion of Municipal Solid Waste and Coal in an Industrial-Scale Circulating Fluidized Bed Boiler

Modeling of Single Coal Particle Combustion in O2/N2 and O2/CO2 Atmospheres under Fluidized Bed Condition

Modeling Research On Char Particle Combustion Behavior In Cfb Condition

CFD Modelling Applied to the Co-Combustion of Paper Sludge and Coal in a 130 t/h CFB Boiler

Combustion Experiment and Gray Relational Analysis of Coal Water Slurry Balls in Fluidized Bed

CFD Modeling of Oxy-Coal Combustion in Circulating Fluidized Bed

Application of Different Combustion Models for Simulating the Co-combustion of Sludge with Coal in a 100 MW Tangentially Coal-Fired Utility Boiler

Numerical Investigation on Development of Initial Ash Deposition Layer for a High-Alkali Coal

Research on CFB Boiler Large Proportion Coal Slime Co-combustion Test

Modeling of the axial distributions of volatile species in a circulating fluidized bed boiler

A six-parameter model to predict ash formation in a CFB boiler

Effect of particle system on slag formation and shedding characteristics of high alkali metal coal in full-scale circulating fluidized bed boiler based on Nano-CT

Experimental Study on Slagging Characteristic of Low-volatile Coal Water Slurry in a 220t/h Boiler

Simulation of Ash Deposit in A Pulverized Coal-Fired Boiler

Ash Deposition Characteristics on Heating Surface in Biomass Circulating Fluidized Bed Boiler