Abstract:Zinc oxide (ZnO) films with thicknesses from (9.1 +/- 0.7) to (145 +/- 7) nm were deposited on silicon substrates by ion-assisted electron beam evaporation (EBE), and transformed to a highly (110)-oriented non-polar phase through thermal treatment at temperatures of 300, 500, and 700 degrees C. The structural, morphological and optical properties of the ZnO thin films were systematically characterized using transmission electron microscopy (TEM), X-ray diffraction (XRD), atomic force microscopy (AFM), spectroscopic ellipsometry (SE), and photoluminescence (PL). The XRD and AFM results illustrate that the deposited ZnO films evolved from an X-ray amorphous structure to the polycrystalline hexagonal wurtzite structure with increasing thickness and experienced a crystallographic plane improvement from (102) to the (110) non-polar phase during annealing. The dielectric functions of the whole layer are mainly affected by the dielectric responses near the surface of ZnO nanocrystals and show an upward trend with nanocrystal growth, induced by thickness and annealing temperature. The optical band gaps were also investigated and correlated with the structural properties. In the PL spectra, a strong ultraviolet luminescence (UVL) band and a weak visible green luminescence (GL) band were observed. The intensity ratio of UVL and GL-associated with crystal quality-agrees with the results acquired from other measurements. The two determinants for highly (110)-oriented non-polar ZnO films are the suppression of growth in the (002) direction by ion bombardment and the promotion of the (110) plane induced by diffusion energy during annealing. (C) 2017 Elsevier B.V. All rights reserved.

Highly Oriented and Transparent Polycrystalline ZnO Films Prepared by RF Actively Sputtering Technique

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Effect of Nucleation and Growth Kinetics on the Electrical and Optical Properties of Undoped ZnO Films

The Effects of Oxygen Partial Pressure and Substrate Temperature on the Structural and Optical Properties of Zno Films

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Deposition and Characterization of AZO Thin Films on Flexible Glass Substrates Using DC Magnetron Sputtering Technique

Characteristics of ZnO Films Prepared by Ultrasonic Spray Pyrolysis Method

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Transparent conductive F-doped SnO 2 films prepared by RF reactive magnetron sputtering at low substrate temperature

Highly transparent and conducting fluorine-doped ZnO thin films prepared by pulsed laser deposition

Highly Transparent Conductive F-doped ZnO Films in Wide Range of Visible and Near Infrared Wavelength Deposited on Polycarbonate Substrates

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Structural and Optical Properties of Highly (110)-Oriented Non-Polar ZnO Evaporated Films on Si Substrates

Transparent and conductive Ga-doped ZnO films grown by RF magnetron sputtering on polycarbonate substrates

Room Temperature Growth and Properties of ZnO Films by Pulsed Laser Deposition

Investigation on the Structural and Optical Properties of ZnO Thin Films Prepared by Sol-Gel Method

Physical and Optical Properties of ZnO Thin Films Grown by DC Sputtering Deposition

Structural and Optical Properties of ZnO Thin Films Prepared by Sol–gel Method with Different Thickness

Transparent Conductive Al-Doped Zno Thin Films Grown at Room Temperature

A study on Ti-doped ZnO transparent conducting thin films fabricated by pulsed laser deposition

Structures and Electric Properties of RF Sputtered ZnO Films