Technical Engineering of Flue Gas Desulfurization by Liquid Column Injection

赵旭东,项光明,姚强,肖海涛,徐杰英,马立波

DOI: https://doi.org/10.3969/j.issn.1006-5377.2004.12.018

2004-01-01

Abstract:The article explicates in detail the technological principles, techni cal features and main properties of flue gas desulfurization technology by liqui d column injection and its application in typical engineering.

What problem does this paper attempt to address?

Progresses on Mechanism Research of Deep Desulfurization of Liquid Fuels by Adsorption

Wang Qingqing,Wu Sufang

DOI: https://doi.org/10.3969/j.issn.1007-3426.2006.03.011

2006-01-01

Abstract:The existing mechanisms of adsorptive desulfurization was reviewed from a view of the molecular diffusion and surface adsorption processes in several aspects: molecule size selection, acidic sites effect and the complexation between sorbents and sulfurides. New technologies of adsorptive desulfurization based on the above mechanisms were introduced. It had been indicated that mechanism research of desulfurization had a significant meaning for further development of novel sorbents and new desulfurization techniques.
Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Xiaotu HU,Xuedong JIANG,Tianle ZHU,Yi WANG,Ruichang QIU,Hongdi ZHANG,Ruinian LI,Keping YAN

DOI: https://doi.org/10.3321/j.issn:0438-1157.2007.04.034

2007-01-01

Abstract:A streamer plasma induced flue gas desulfurization (FGD) technique is reported.An AC/DC superposition electric source generated a spatially well distributed plasma in an industrial scale reactor.Instead of the traditional dry technique,a partitioned wet reactor system was adopted.A streamer plasma oxidation technique was developed to solve the problem in the oxidation of concentrated ammonium sulfite solution.The ammonia slip was well controlled.The liquid byproduct was dried up to form solid ammonium sulfate.Pilot test under the conditions of an initial concentration of 500—1000 μl·L-1 of SO2 demonstrated the desulfurization efficiency greater than 95%.The oxidation efficiency through one cycle reached 50%—70%,the energy consumption in the reactor was less than 3.5W·h·m-3,and the ammonia slip was less than 5 μl·L-1.The byproduct was ammonium fertilizer.Under the conditions of using high concentration OH radicals excited with AC/DC streamer plasmas,an oxidation rate with practical value can be achieved at a sulfite concentration of over 3mol·L-1.
A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

KP Yan,RN Li,TL Zhu,HD Zhang,XT Hu,XD Jiang,H Liang,RC Qiu,Y Wang

DOI: https://doi.org/10.1016/j.cej.2005.09.030

IF: 15.1

2005-01-01

Chemical Engineering Journal

Abstract:An industry-scale semi-wet technological process for flue gas desulfurization by corona discharges is recommended. Its characteristics are: (1) it uses an ac/dc power supply to generate uniformly distributed streamer plasmas; (2) it uses a partitioned wet reactor system in which SO2 in the flue gas is absorbed with ammonia water in its thermal chemical reaction stage and the generated solution is repeatedly sprayed and transferred at an appropriate flow rate to the successive plasma reaction stage under the conditions of keeping liquid flow in balance. In the plasma stage, SO2 absorption by the liquid is enhanced by the electric wind and the sulfites in the solution experiences plasma oxidization; (3) drying up the end liquid to produce powder-typed byproduct and discharging the end gas after heat exchange with the hot gas at the inlet. Through a pilot test of 12,000Nm3/h capacity of flue gas with an initial SO2 concentration of about 500ppm, results of desulfurization rate >95%, energy consumption in the reactor 1.8Wh/Nm3, ammonia slip less than 5ppm and qualified fertilizer byproduct are obtained.
The Techno-economic Analysis of Engineering Units of Flue Gas Suspend Desulfurization by Double Circulating Fluidized Bed

赵旭东,吴少华,秦裕琨,高继慧,马春元

DOI: https://doi.org/10.3969/j.issn.1005-006x.2002.05.007

2002-01-01

Abstract:An engineering example about the technology Double CFB Flue Gas Suspend Desulfurization in application to 75t/h utility boiler is introduced and its engineering results and benefits are analyzed. The flue gas flow rate is 140000m3/h. This technology has some advantages, such as simple technical process, demanding small area, operating stably etc. It is the new technology fit conditions of our country.
Desulfurization Technical for Flue Gas of Boiler in Large Coal Fired Power Plant

许涛,张岗,高翔

DOI: https://doi.org/10.3969/j.issn.1006-3986.2003.01.009

2003-01-01

Abstract:The present state application and the development of flue gas desulfurization domestic technical were introduced. The nation made technical is suitable for large coal fired boiler of power generator in our country, such as the method of wet lime gypsum, cyclic suspended semi drying and humidifying LIFAC, were introduced. A comparison was made between the different methods as well.
Application of Technology to Discharge Desulfurized Wet Flue Gas via a Cooling Tower

Ming Zhai,Peng DONG,Li WANG

DOI: https://doi.org/10.3969/j.issn.1005-006X.2005.04.010

2005-01-01

Abstract:The novel technology of natural draft cooling towers with flue gas injection featuring the plume discharge of desulfurized wet flue gas due to the large thermal momentum of hot wet air in the cooling tower for the fossil-fueled power generation units is introduced. With practical engineering project examples, the design principles for cooling towers with this technology are described.
A Study of Desulfurization Characteristics of a First-grade Gas-liquid Section in the Process of Compound-sprouted Fluidized Flue-gas Desulfurization

高继录,高继慧,陈晓利,高建民

2008-01-01

Abstract:The authors have presented a novel semi-dry-method of flue-gas purification process and conducted an experimental study of the desulfurization characteristics of a first-grade gas-liquid main reaction section in the above process by employing a real-time on-line SO2 spectrum analytic system.The influence of the following six factors on the desulfurization efficiency was analyzed in detail:flue gas flow speed,slurry atomization quality,flue gas temperature,SO2 concentration at the inlet,circulating ash concentration and slurry feeding mode etc.In addition,the change of SO2 concentration along the flow path was measured.The test results show that at optimized operating-condition parameters,the desulfurization efficiency in the section under investigation can be higher than 55%.The circulating ash concentration has a conspicuous influence assessed at 6% on the desulfurization characteristics of the section.Through an optimization of slurry feeding mode,the desulfurization efficiency can be enhanced by about 3%.The slurry atomization quality has also an obvious influence of about 2%～3% on the desulfurization efficiency of the section.
Fuzzy Comprehensive Evaluation on Flue Gas Desulphurization Technologies

许涛,张岗,刘波,高翔,骆仲泱,岑可法

DOI: https://doi.org/10.3969/j.issn.1007-290x.2002.04.004

2002-01-01

Abstract:This article introduces the development and application of the flue gas desulphurization technologies. Based on the 2×300 MW coal fired units of a thermal power plant, using the fuzzy comprehensive evaluating method, this article provides a integration evaluating method and educes the best flue gas desulphurization technology.
Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

CHENG Feng,LUO Zhong-yang,GAO Xiang,WANG Jun,GUO Rui-tang,CEN Ke-fa

DOI: https://doi.org/10.3785/j.issn.1008-973x.2005.11.028

2005-01-01

Abstract:A new type of impinging liquid column tower for wet flue gas desulphurization(WFGD) was built in laboratory.The effects of different geometry and operation parameters on the desulphurization efficiency in the scrubbers were studied on an experimental platform.The main influencing factors include: slurry flux density,flue gas velocity,pH in the circulating tank,inlet mass concentration of SO_2,temperature of the inlet flue gas,and the configurable factors such as height of block and cross-section of scrubber.The results indicate that the desulphurization efficiency increases with increasing slurry flux density,flue gas velocity,pH in the circulating tank and inlet temperature of the flue gas,but that the efficiency decreases with increasing inlet mass concentration of SO_2. Decrease of the scrubber cross-section or the distance between the impinging plate and the nozzle results in better atomization,which greatly increases the desulphurization efficiency.With optimized geometry and operation parameters,the desulphurization efficiency can be improved to 95%.
The Technology of Coal-fired Flue Gas Dechlorination for Realizing Zero-discharge of Desulfurization Wastewater and Its Influences on Boiler

YANG Jianguo,GENG Ziwen,YUAN Weizhong,CHEN Xijiong,TENG Weiming,LIU Chang,ZHAO Hong

DOI: https://doi.org/10.13334/j.0258-8013.pcsee.171008

2018-01-01

Abstract:The zero-discharge of desulfurization wastewater has become a hot environmental issue. Coal-fired flue gas dechlorination is a new technology to achieve zero-discharge of desulfurization wastewater. The atomized alkaline solution is sprayed into the flue before the precipitator to absorb strong acid gases such as HCl. Then the reaction products will be removed with fly ash by precipitator synergistically. By reducing the mass concentration of Cl-in the flue gas at the inlet of the desulfurization tower, the amount of desulfurization wastewater can be reduced effectively. While the desulfurization wastewater after reduction being used as the solvent of alkaline, zero-discharge of desulfurization wastewater will be realized finally. When NaOH is used as the alkaline substance, and the Na/Cl(in mole) is about 5, the efficiency of dechlorination could reach more than 70％. The amount of desulfurization waste water of a 300MW unit can be reduced from 3. 1m3/h to 0. 88m3/h. In addition, the technology will not only remove HCl, but also can remove SO2and SO3in the flue gas. It has great significance for the prevention of low temperature corrosion, especially under the case of ultra-low emission. It also has certain positive significance for the operation of ESP and WFGD. Compared to other technologies of processing desulfurization wastewater, coal-fired flue gas dechlorination technology has the advantages of simple system, low cost, good security, strong adaptability, no secondary pollution and so on. It has a good application prospect.
Introduction on spray dry desulfurization technology

Yi-feng CAI

DOI: https://doi.org/10.3969/j.issn.1674-8069.2005.02.006

2005-01-01

Abstract:The technological principle and process of spray dry desulfurization, and its application to flue gas SO_2 control are briefly described.
EXPERIMENTAL STUDY AND INDUSTRIAL APPLICATION OF TURBULENT FLOW TYPE WET FLUE GAS DESULFURIZATION AND DUST-EIMINATION TECHNOLOGY

程峰,高翔,骆仲泱,方梦祥,施正伦,岑可法

DOI: https://doi.org/10.3969/j.issn.1002-3364.2002.06.012

2002-01-01

Abstract:The fundamental principle of integrated wet flue gas desulfurization and dust-elimination technology has been presented. Through experiments, the resistance properties of turbulent flow layer composed of three different structural turbulent spheres are studied, and the infuencing factors, such as molar ratio of Ca and S, and lequid and gas ratio etc., upon the deaulfurization performance are analysed. Then, the industrial application of the said technology and monitoring results are given.
TECHNOLOGY OF WET DESULFURIZATION OF FLUE GAS

Zhang Jianbin,Ma Kai,Li Qiang,Chen Guohua,Zhang Pengyan,Wei Xionghui

DOI: https://doi.org/10.3969/j.issn.1003-9384.2007.02.021

2007-01-01

Abstract:The mechanism and characteristics of various wet flue gas desulfurization (WFGD) technologies were reviewed. Lime/limestone system and sodium alkali may be utilized in single pass desulfurization process, but may cause secondary environmental pollution. For ammonia method, the key factor is the stabilization of the ammonia in the desulfurization solution. Alcohol-amine desulfurization and biodesulfurization methods need the regeneration of the solution in order to decrease losses and keep the performance of the solutions. The regeneration process of the desulfurization solutions containing sulfur compounds assisted by microorganism, as a new method, will represent the trend of development.
Recent Advances in Flue Gas Desulphurization in Coal-Fired Power Plant

Weiyang Fei

2011-01-01

Abstract:Flue gas desulfurization(FGD) is a significant technique to control the SO_2 discharge of industrial enterprises that consume coal.With advantages of high efficient,large handling capacity and low cost,FGD by absorption with chemicals is widely used in the practice.Recent advances of FGD by absorption with chemicals are summarized in this paper,with a brief discussion of their characteristics.Seawater FGD,a promising technique with simple process, high efficient and environmental friendly,is economic and reliable.It has been widely used in power plants located along the coast.However,there are some disadvantages in gas and liquid mal distributions due to the huge size of the absorber,which lower the desulfurization efficiency.In this paper,gas and liquid distributions in the absorption column were analyzed using Computational Fluid Dynamic Simulation(CFD).Results showed the flue gas was badly distributed inside the column.Liquid distribution also needs to improve.Preliminary gas-liquid absorption experiments indicated that the novel packing proposed can lower the pressure drop and increase the desulfurization efficiency.
THE INTEGRATED WET FLUE GAS DESULFURIZATION AND DUST SEPARATION TECHNOLOGY

Zeng Lingke,Niu Yange,Liu Tao,Wang Hui,Cheng Xiaosu,Shui Anze

DOI: https://doi.org/10.3969/j.issn.1006-2874.2009.01.008

2009-01-01

Abstract:The technologies of fuel dust removal and sulfur removal are mature and economical application technolo-gies, of which the wet sulfur removal technology is more popularized and extensively applied. The paper de-scribed the mechanism, efficiency, cost of several desulphurization technologies and specially introduced the desulphurization mechanism and dual alkali flue gas desulphurization process in rotating-stream-tray scrub-ber.
Experimental Study of Semi-dry Flue Gas Desulfurization in Circulating Suspension Fluidized Bed

GAO Xiang,LIU Hai-jiao,TENG Bin,LUO Zhong-yang,NI Ming-jiang,CEN Ke-fa

DOI: https://doi.org/10.3969/j.issn.1674-7607.2006.05.025

2006-01-01

Abstract:An experimental pilot installation for dealing with 1500Nm3/h flue gas has been erected and studies on semi-dry desulfurization technology of flue gas in circulating suspended fluidized beds conducted.The influence of operational parameters(including lingering time of the flue gas in the absorption tower,Ca/S ratio,remoteness from the adiabatic saturation temperature,size of the slurry drops,SO_2 concentration at entrance,flue gas temperature at entrance,etc.) and factors like recirculation of desulfurized ash,on the desulfurization efficiency of the desulfurization tower and that of the whole system,have been investigated.Study results show that among operation parameters,changes in remoteness from the adiabatic saturation temperature,the Ca/S ratio and the slurry drop size all have a noticeable effect on the system's desulfurization efficiency. An increase of recirculating ash is also advantageous for boosting desulfurization efficiency.Figs 18,tables 2 and refs 9.
Application of Wet Turbulence Integrated De-SOx and De-dusting Technology

周瑞福,李建生,尹宾宾,郑如燕,高翔,骆仲泱,岑可法

DOI: https://doi.org/10.3969/j.issn.1004-8774.2002.06.011

2002-01-01

Abstract:The article introduces some FGD technology used in a 35t/h project developed by Shanxi yangmei Group , Shanxi province. On the base of the real practice and some relative experiments, It tries to demonstrate the theory and some characteristics of this technology ,and also gives some descriptions on its de-dust performance in a high-density dust-distributed conditions .
Experimental Study of Gas-solid Flows in a Circulating Fluidized Bed of Flue Gas Desulfurization by the Use of a Particle Dynamics Analyzer

董勇,马春元,秦裕琨

DOI: https://doi.org/10.3969/j.issn.1001-2060.2004.05.003

2004-01-01

Abstract:Flue gas desulfurization technology is proposed on the basis of a circulating fluidized bed composed of a two-stage separation system. With the help of a particle dynamics analyzer measurements were taken of particle transverse and axial velocities, particle diameter as well as concentration distribution at different height levels in the bed. As a result, obtained were the momentary pulsation characteristics of the gas-solid flows and overall gas-solid flow behavior in the fluidized bed. These results can provide a solid basis for the structural design and optimization of new technology schemes of a flue gas desulfurization process.
[Intermediate Experiment and Mechanism Analysis of Flue Gas Desulfurization Technology by Circulating Fluidized Bed].

Xudong Zhao,Shaohua Wu,Chunyuan Ma,Yukun Qin

DOI: https://doi.org/10.3321/j.issn:0250-3301.2002.02.023

2002-01-01

Abstract:A new Circulating Fluidized Bed was designed for intermediate experiment of flue gas desulphurization, in which the flue gas flow rate was 3500 m3/h. By using it, the basic experiments were carried out to study the influence of Ca/S and supersaturated temperature on desulphurization efficiency and the effect of the recycling solid particle in the sulfur removal column on desulphurization performance. The results showed when Ca/S = 1.2, the desulphurization efficiency was increased by 15% through the recycle of solid particle; the gas velocity inside the bed could be designed higher. The mechanism analysis were also studied and the method to increase effective resident time was introduced.
The coal desulfurization technology of microbe with lixiviation techniques

QIU Ya-lin,YANG Li,XU Shou-dong,YU Bing-feng

DOI: https://doi.org/10.3969/j.issn.1671-749x.2006.01.013

2006-01-01

Abstract:This paper expounds the technology and the research process in the coal's biodesulfurization,and introduces the difficulties within it,while probing its future.

Technical Engineering of Flue Gas Desulfurization by Liquid Column Injection

Progresses on Mechanism Research of Deep Desulfurization of Liquid Fuels by Adsorption

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

The Techno-economic Analysis of Engineering Units of Flue Gas Suspend Desulfurization by Double Circulating Fluidized Bed

Desulfurization Technical for Flue Gas of Boiler in Large Coal Fired Power Plant

Application of Technology to Discharge Desulfurized Wet Flue Gas via a Cooling Tower

A Study of Desulfurization Characteristics of a First-grade Gas-liquid Section in the Process of Compound-sprouted Fluidized Flue-gas Desulfurization

Fuzzy Comprehensive Evaluation on Flue Gas Desulphurization Technologies

Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

The Technology of Coal-fired Flue Gas Dechlorination for Realizing Zero-discharge of Desulfurization Wastewater and Its Influences on Boiler

Introduction on spray dry desulfurization technology

EXPERIMENTAL STUDY AND INDUSTRIAL APPLICATION OF TURBULENT FLOW TYPE WET FLUE GAS DESULFURIZATION AND DUST-EIMINATION TECHNOLOGY

TECHNOLOGY OF WET DESULFURIZATION OF FLUE GAS

Recent Advances in Flue Gas Desulphurization in Coal-Fired Power Plant

THE INTEGRATED WET FLUE GAS DESULFURIZATION AND DUST SEPARATION TECHNOLOGY

Experimental Study of Semi-dry Flue Gas Desulfurization in Circulating Suspension Fluidized Bed

Application of Wet Turbulence Integrated De-SOx and De-dusting Technology

Experimental Study of Gas-solid Flows in a Circulating Fluidized Bed of Flue Gas Desulfurization by the Use of a Particle Dynamics Analyzer

[Intermediate Experiment and Mechanism Analysis of Flue Gas Desulfurization Technology by Circulating Fluidized Bed].

The coal desulfurization technology of microbe with lixiviation techniques