Abstract:Crystalline silicon has a complicated phase transition mechanism, which has received extensive attention in the research field of phase diagram, and the deformation mechanism of silicon crystals under dynamic loading is the current research hotspot. In order to reveal its deformation and phase transition behaviors under intensive dynamic loading, molecular dynamics method was used to simulate the shock compression behavior of single crystal silicon along the crystal directions [001], [110] and [111] at an initial ambient temperature of 300 K, respectively. All simulations were carried out basing on the classical open-source codes LAMMPS and a Tersoff interatomic potential was adopted to describe the material responses of silicon under dynamic compression. Before shock loading, periodic boundary conditions were applied along the three independent directions, and an NPT ensemble was used to equilibrate the systems; then shock compression was applied by using the piston method, where a virtual piston wall impinges the sample such that the particle velocity in the sample is the same as the piston speed after the shock reaches a steady state. The shock particle velocities varied from 0.3 km/s to 3.2 km/s, and a timestep of 0.001 ps was adopted. During the stress wave formation and propagation, the simulation system was in the NVE ensemble with the absence of temperature control. The loading method and effect are similar to typical plane impact experiments. The results show that with the increase of shock particle velocity, the shear stress of single crystal silicon increases gradually and then decreases sharply due to the structural phase change. Both the phase transition threshold and the phase transition mechanism are anisotropic. Among them, a variety of solid-solid phase transitions and solid-liquid phase transitions are observed under shock compression along the [001] crystal direction. The phenomenon of solid-liquid coexistence is highly consistent with the recent international experiments. The research results provides new nano-scale results to support the study of phase transition of crystalline silicon under dynamic loading.

Research on Elastic-Plastic Transition and Hardening Effect for Monocrystalline Silicon Surfaces

Atomistic Investigations of Single-Crystal Silicon with Pre-Existing Defects

Nanoindentation Characterization of Single-Crystal Silicon with Oxide Film

Numerical and experimental investigation on ductile deformation and subsurface defects of monocrystalline silicon during nano-scratching

Influence of Anisotropy on Material Removal and Deformation Mechanism Based on Nanoscratch Tests of Monocrystal Silicon

Anisotropic Deformation of 4H-Sic Wafers: Insights from Nanoindentation Tests

Study on shock compression phase transition of single crystal silicon based on molecular dynamics simulation

Experimental Study on the Surface Cutting Mechanical Properties of Single Crystal Silicon in Micro-Nano Scale

Molecular dynamics study of crystal orientation effect on surface generation mechanism of single-crystal silicon during the nano-grinding process

Molecular dynamics simulation of subsurface damage mechanism during nanoscratching of single crystal silicon

Cutting Performance of Single Crystal Silicon Anisotropic Surface in Micro-nano Scale

Coupled SPH-FEM modeling of Berkovich indenter scratching of single-crystal silicon

Towards a deeper understanding of plastic deformation in mono-crystalline silicon

Reveal the Deformation Mechanism of (110) Silicon from Cryogenic Temperature to Elevated Temperature by Molecular Dynamics Simulation

Investigation on surface generation mechanism of single-crystal silicon in grinding: Surface crystal orientation effect

Molecular Dynamics Simulation on the Mechanism of Nanometric Machining of Single-Crystal Silicon

Study on the Removal Depth of the Surface Plastic Domain of Silicon-Modified Silicon Carbide

Study on the Vertical Ultrasonic Vibration-Assisted Nanomachining Process on Single-Crystal Silicon

On the deformation mechanism of SiC under nano-scratching: An experimental investigation

Nanoindentation of polysilicon and single crystal silicon: Molecular dynamics simulation and experimental validation

Investigation of machining mechanism of monocrystalline silicon in nanometric grinding