Abstract:Herein, the evolution of ZnO structures from hexagonal disk to prismoid, prism and pyramid was found via a facile two-step low temperature hydrothermal reaction, and the evolution was achieved by only adjusting the pH value of the reactive solution without the assistance of a template or a surfactant. The characterization results showed that the precursor (hexagonal Zn-5(OH)(8)Cl-2 center dot 2H(2)O disk) played a key role in the morphology evolution of ZnO during the early stage of the growth process and that the disks tended to stack together layer by layer in both directions (up and down) to form prismoid, prism and pyramid structures with the increase in pH value from 7 to 10. After calcination, the corresponding hexagonal ZnO microstructures were obtained. This structure evolution resulted in the weakening dominance of the (0001) plane in the total exposed crystal facets. Furthermore, despite the similar specific surface areas of the four hexagonal ZnO microstructures, the gas sensing properties of the sensors based on these microstructures deteriorated sequentially. At a working temperature of 330 degrees C, the ZnO disk with the most exposed (0001) plane showed the highest gas response toward ethanol, which was nearly 2, 3, and 6 times higher than those of the prismoid, prism and pyramid structures, respectively. This superior gas sensing performance strongly depends on the predominantly exposed polar facets (0001), which can provide more active sites for oxygen adsorption and subsequent reaction with the detected gas than other apolar facets. It demonstrates that the (0001) crystal facet plays a significant role in the gas sensing behavior of ZnO. This research will bring some inspiration to researchers for the fabrication of a high performance ZnO gas sensor as well as other metal oxides.

Controllable Growth and Gas Sensitivity Properties of Zinc Oxide Nanocrystalline by Solid-State Reaction

The growth of nanoscale ZnO films by pulsed-spray evaporation chemical vapor deposition and their structural, electric and optical properties

Controlled Crystal Growth of ZnO Nanobelts by Chemical Vapor Deposition Method

Preparation and gas sensing properties of hexagonal zinc oxide regulated by surface modification

Evolution of ZnO microstructures from hexagonal disk to prismoid, prism and pyramid and their crystal facet-dependent gas sensing properties

Gas-Sensing Property of A Nitrogen-Doped Zinc Oxide Fabricated by Combustion Synthesis

Enhanced performance of the tangerines-like CuO-based gas sensor using ZnO nanowire arrays

Liquid-Phase Growth of Nanocrystalline ZnO Thin Films and Their Gas-Sensitive Properties

Gas Sensitivity Mechanism of Nanometer Particle ZnO Thin Films

Controllable hydrothermal synthesis of Al-doped ZnO with different microstructures, growth mechanisms, and gas sensing properties

Porous and Single-Crystalline ZnO Nanobelts: Fabrication with Annealing Precursor Nanobelts, and Gas-Sensing and Optoelectronic Performance

Pressure Induced Phase Transformation in Nanocrystal SnO 2

Direct Growth Of Zno Nanodisk Networks With An Exposed (0001) Facet On Au Comb-Shaped Interdigitating Electrodes And The Enhanced Gas-Sensing Property Of Polar {0001} Surfaces

Direct growth of ZnO nanodisk networks with an exposed (0 0 0 1) facet on Au comb-shaped interdigitating electrodes and the enhanced gas-sensing property of polar {0 0 0 1} surfaces

Growth and Electrical Properties of Zinc Oxide Nanowires.

Gas-sensing Property Improvement of ZnO by Hierarchical Flower-Like Architectures

Hydrothermal synthesis of ZnO nanobelts and gas sensitivity property

Growth Mechanism of ZnO Nanostructures in Wet-Oxidation Process

Selective Growth and Properties of Zinc Oxide Nanostructures

Effect of Alkali Source on Crystal Regulation and Ethanol Gas Sensing Properties of Nano-ZnO

Controlled evolution of surface microstructure and phase boundary ZnO nanoparticles for the multiple sensitization effects on triethylamine detection