Abstract:Herein, the evolution of ZnO structures from hexagonal disk to prismoid, prism and pyramid was found via a facile two-step low temperature hydrothermal reaction, and the evolution was achieved by only adjusting the pH value of the reactive solution without the assistance of a template or a surfactant. The characterization results showed that the precursor (hexagonal Zn-5(OH)(8)Cl-2 center dot 2H(2)O disk) played a key role in the morphology evolution of ZnO during the early stage of the growth process and that the disks tended to stack together layer by layer in both directions (up and down) to form prismoid, prism and pyramid structures with the increase in pH value from 7 to 10. After calcination, the corresponding hexagonal ZnO microstructures were obtained. This structure evolution resulted in the weakening dominance of the (0001) plane in the total exposed crystal facets. Furthermore, despite the similar specific surface areas of the four hexagonal ZnO microstructures, the gas sensing properties of the sensors based on these microstructures deteriorated sequentially. At a working temperature of 330 degrees C, the ZnO disk with the most exposed (0001) plane showed the highest gas response toward ethanol, which was nearly 2, 3, and 6 times higher than those of the prismoid, prism and pyramid structures, respectively. This superior gas sensing performance strongly depends on the predominantly exposed polar facets (0001), which can provide more active sites for oxygen adsorption and subsequent reaction with the detected gas than other apolar facets. It demonstrates that the (0001) crystal facet plays a significant role in the gas sensing behavior of ZnO. This research will bring some inspiration to researchers for the fabrication of a high performance ZnO gas sensor as well as other metal oxides.

Controllable hydrothermal synthesis of Al-doped ZnO with different microstructures, growth mechanisms, and gas sensing properties

Synthesis of flower-like Al doped ZnO microstructures by hydrothermal process and analysis of their gas sensing properties

Synthesis of Al Doped ZnO with a Novel Rice Microstructure by Hydrothermal Process and Analysis of Their Gas Sensing Properties

Hydrothermal Synthesis and Growth Mechanisms of Different ZnO Nanostructures and Their Gas-Sensing Properties

Room-temperature solid state synthesis of ZnO/α-Fe2O3 hierarchical nanostructures and their enhanced gas-sensing properties

Enhanced performance of the tangerines-like CuO-based gas sensor using ZnO nanowire arrays

Controllable Synthesis of Prism- and Lamella-Like ZnO and Their Gas Sensing

Synthesis of morphology-controlled ZnO microstructures via a microwave-assisted hydrothermal method and their gas-sensing property.

Hmt Assisted Hydrothermal Synthesis of Various Zno Nanostructures: Structure, Growth and Gas Sensor Properties

Synthesis of hierarchical ZnO nanostructure assembled by nanorods and their performance for gas sensing

Morphological evolution of flower-like ZnO microstructures and their gas sensing properties

Facile Non-Template Synthesis Mesoporous Hollow Sphere Zinc Oxide for High Gas Sensitive Ethanol Detection

Synthesis, Optical and Gas Sensitive Properties of Large-Scale Aggregative Flowerlike ZnO Nanostructures Via Simple Route Hydrothermal Process

Microstructure and Gas Sensing Properties of the ZnO Thick Film Treated by Hydrothermal Method

Synthesis of Mesoporous Hollow Sphere Zinc Oxide Through Ladder Temperatures for High Sensitive Ethanol Detection

Room-Temperature Solid State Synthesis Of Zno/Alpha-Fe2o3 Hierarchical Nanostructures And Their Enhanced Gas-Sensing Properties

Synthesis and gas sensor properties of flower-like 3D ZnO microstructures

Evolution of ZnO microstructures from hexagonal disk to prismoid, prism and pyramid and their crystal facet-dependent gas sensing properties

Hydrothermal Synthesis of Hierarchical Flower-Like ZnO Nanostructure and Its Enhanced Ethanol Gas-Sensing Properties

Hydrothermal synthesis of various hierarchical ZnO nanostructures and their methane sensing properties.

Controlled Synthesis of Zno Hollow Microspheres Via Precursor-Template Method and Its Gas Sensing Property