Abstract:This paper presents a monolithically integrated aptasensor composed of a piezoresistive microcantilever array and an on-chip signal processing circuit. Twelve microcantilevers, each of them embedded with a piezoresistor, form three sensors in a Wheatstone bridge configuration. The on-chip signal processing circuit consists of a multiplexer, a chopper instrumentation amplifier, a low-pass filter, a sigma-delta analog-to-digital converter, and a serial peripheral interface. Both the microcantilever array and the on-chip signal processing circuit were fabricated on the single-crystalline silicon device layer of a silicon-on-insulator (SOI) wafer with partially depleted (PD) CMOS technology followed by three micromachining processes. The integrated microcantilever sensor makes full use of the high gauge factor of single-crystalline silicon to achieve low parasitic, latch-up, and leakage current in the PD-SOI CMOS. A measured deflection sensitivity of 0.98 × 10 − 6 nm −1 and an output voltage fluctuation of less than 1 μV were obtained for the integrated microcantilever. A maximum gain of 134.97 and an input offset current of only 0.623 nA were acquired for the on-chip signal processing circuit. By functionalizing the measurement microcantilevers with a biotin-avidin system method, human IgG, abrin, and staphylococcus enterotoxin B (SEB) were detected at a limit of detection (LOD) of 48 pg/mL. Moreover, multichannel detection of the three integrated microcantilever aptasensors was also verified by detecting SEB. All these experimental results indicate that the design and process of monolithically integrated microcantilevers can meet the requirements of high-sensitivity detection of biomolecules.

A Reflective Mirror Microcantilevers-Based Biosensor for Biochemical Detection

A Reflective Grating Microcantilever Biosensor

A Novel Optical Fiber Reflective Read out Microcantilever Biosensor

Microcantilever (MCL) Biosensing

A Grating-Based Optical Readout Method for Microcantilever Biosensor

Fabrication and characterization of SiO2 microcantilever for microsensor application

A Symmetrical Optical Waveguide Based Surface Plasmon Resonance Biosensing System

Microcantilever Biosensors for Chemicals and Bioorganisms

A Grating Microcantilever Biosensor Based on Diffraction Spectrum Feedback Balanced

Fabrication and Characterization of Sio2 Microcantilever for High Sensitive Moisture Sensor

Micromachined SiO 2 microcantilever for high sensitive moisture sensor

Highly-Sensitive Optical Biosensors Based on Silicon-On-Insulator Nanowire Waveguide

Analysis and Design of Refractive Index Biosensors Based on Single Silicon Nanobeam Cavity

Silicon-on-Insulator Nanowire Based Optical Waveguide Biosensors

Microfluidics-Integrated Cascaded Double-Microring Resonators for Label-Free Biosensing

Highly-Sensitive Silicon-On-Insulator Sensor Based on Two Cascaded Micro-Ring Resonators with Vernier Effect

Optical Ring Resonator Biosensor for Small Molecule Detection

Piezoresistive Bridge Microcantilevers Biosensor Based on Soi Wafer for Glucose Detecting

A Monolithically Integrated Microcantilever Biosensor Based on Partially Depleted SOI CMOS Technology

Biochemical Sensors Based on Piezoresistive Microcantilevers