Abstract:This paper presents a monolithically integrated aptasensor composed of a piezoresistive microcantilever array and an on-chip signal processing circuit. Twelve microcantilevers, each of them embedded with a piezoresistor, form three sensors in a Wheatstone bridge configuration. The on-chip signal processing circuit consists of a multiplexer, a chopper instrumentation amplifier, a low-pass filter, a sigma-delta analog-to-digital converter, and a serial peripheral interface. Both the microcantilever array and the on-chip signal processing circuit were fabricated on the single-crystalline silicon device layer of a silicon-on-insulator (SOI) wafer with partially depleted (PD) CMOS technology followed by three micromachining processes. The integrated microcantilever sensor makes full use of the high gauge factor of single-crystalline silicon to achieve low parasitic, latch-up, and leakage current in the PD-SOI CMOS. A measured deflection sensitivity of 0.98 × 10 − 6 nm −1 and an output voltage fluctuation of less than 1 μV were obtained for the integrated microcantilever. A maximum gain of 134.97 and an input offset current of only 0.623 nA were acquired for the on-chip signal processing circuit. By functionalizing the measurement microcantilevers with a biotin-avidin system method, human IgG, abrin, and staphylococcus enterotoxin B (SEB) were detected at a limit of detection (LOD) of 48 pg/mL. Moreover, multichannel detection of the three integrated microcantilever aptasensors was also verified by detecting SEB. All these experimental results indicate that the design and process of monolithically integrated microcantilevers can meet the requirements of high-sensitivity detection of biomolecules.

Demonstration of Microcantilever-Based Sensor Array with Integrated Microfluidics

Optical Micro/nanofibre Embedded Soft Film Enables Multifunctional Flow Sensing in Microfluidic Chips

Transient Deflection Response in Microcantilever Array Integrated with Polydimethylsiloxane (PDMS) Microfluidics.

Microcantilever array sensors with integrated PDMS microfluidics

DEMONSTRATION OF MICROCANTILEVER BIOSENSOR ARRAY WITH IN-PLANE PHOTONIC TRANSDUCTION MECHANISM

Chemical Specificity in Nanomechanical Sensors

Micromachined SiO 2 microcantilever for high sensitive moisture sensor

Mechanical and Electronic Approaches to Improve the Sensitivity of Microcantilever Sensors.

Fabrication and Characterization of Sio2 Microcantilever for High Sensitive Moisture Sensor

Improved Surface Modification Approach for Micromechanical Biosensors

A Monolithically Integrated Microcantilever Biosensor Based on Partially Depleted SOI CMOS Technology

Demonstration of Microcantilever Array with Simultaneous Readout Using an In-Plane Photonic Transduction Method

Micro-cantilever resonance sensor for biomolecular detection by using self-assembly nano-particles

Parylene-coated NMOSFET-embedded cantilevers for surface stress sensing in liquid environment.

Chemical and Biological Sensors Based on Microcantilever Structure

Micromechanical cantilever-based biosensors

A simple optical sequential illumination for microcantilever array

A Microfluidic Sensor for Dynamic Surface Tension Measurement

Cantilever-based Transducer for Molecules Configuration Research

Design and Realization of New Optical Sequential Readout for Micro-cantilever Array

Multiple-input microcantilever sensors