Abstract:Thermal annealing is a widely used strategy to enhance semiconductor device performance. However, the process is complex for multi-material multi-layered semiconductor devices, where thermoelastic stresses from lattice constant and thermal expansion coefficient mismatch may create more defects than those annealed. We propose an alternate low temperature annealing technique, which utilizes the electron wind force (EWF) induced by small duty cycle high density pulsed current. To demonstrate its effectiveness, we intentionally degrade AlGaN/GaN high electron mobility transistors (HEMTs) with accelerated OFF-state stressing to increase ON-resistance ∼182.08% and reduce drain saturation current ∼85.82% of pristine condition at a gate voltage of 0 V. We then performed the EWF annealing to recover the corresponding values back to ∼122.21% and ∼93.10%, respectively. The peak transconductance, degraded to ∼76.58% of pristine at the drain voltage of 3 V, was also recovered back to ∼92.38%. This recovery of previously degraded transport properties is attributed to approximately 80% recovery of carrier mobility, which occurs during EWF annealing. We performed synchrotron differential aperture x-ray microscopy measurements to correlate these annealing effects with the lattice structural changes. We found a reduction of lattice plane spacing of (001) planes and stress within the GaN layer under the gate region after EWF annealing, suggesting a corresponding decrease in defect density. Application of this low-temperature annealing technique for in-operando recovery of degraded electronic devices is discussed.

Defect Losses under Different Processes, Stress, Recovery, and Anneal Conditions

Defect Loss: A New Concept for Reliability of MOSFETs

Defect loss and its physical processes

Off-state Avalanche Breakdown Induced Degradation in 20 V NLDMOS Devices

Off-state Avalanche-Breakdown-induced On-Resistance Degradation in SGO–NLDMOS

New Insights Into Defect Loss, Slowdown, and Device Lifetime Enhancement

Process-induced defects in nitrogen doped Czochralski silicon in diode processes

J un 2 01 9 Ultraslow Dynamic Annealing of Neutron-induced Defects in n-type Silicon

Multiple Defects Cause Degradation After High Field Stress in AlGaN/GaN HEMTs

Evolution of secondary defects in arsenic implanted Si

Impact of Electrical Stress on Defect Generation in Thin GeO<sub>2</sub>/Ge Gate Stacks Fabricated by Thermal Oxidation

Extended Defects in Nitrogen-Doped Czochralski Silicon During Diode Process

Defects Evolution in N-Type 4H-Sic Induced by Electron Irradiation and Annealing

Degradation of AlGaN/GaN Metal–insulator–semiconductor High Electron Mobility Transistors under Off-State Electrical Stress

Study of Local Stress Using Stress-Absorbing Si Diaphragm

Effect of Stresses on Defect Nucleation in Si1-xGex/Si Heteroepitaxial Systems

Low temperature recovery of OFF-state stress induced degradation of AlGaN/GaN high electron mobility transistors

Evolution Of Defects And Defect Clusters In Beta-Sic Irradiated At High Temperature

Observation Of Degradation And Recovery Of Stacked Hfox/Zroy/Hfox Mosfets

Evolution of Defects and Defect Clusters in β-SiC Irradiated at High Temperature

Suppression of Stress-Induced Defects in FinFET by Implantation and STI Co-Optimization