Abstract:This article proposes a novel ultralow specific ON-resistance (${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ ) triple reduced surface field (RESURF) lateral double-diffused MOSFET (LDMOS) with sandwich n-p-n layer. Compared with the conventional triple RESURF LDMOS with n-type top layer (NTTR LDMOS), the new structure is characterized by an additional N-buried layer below the P-buried layer. Due to the introduction of N-buried layer, the concentration of N-top layer will decrease to ensure charge balance, thus making the surface electric field distribution better and the higher additional doping introduced by N-top and N-buried layers can be achieved. The dose and implantation energy of n-p-n layers were simulated and optimized. Furthermore, in order to eliminate the premature avalanche breakdown occurring in the source-centered termination region, substrate termination technology (STT) is applied to avoid the high electric field peaks generated in the curved source region with small curvature radius. But the use of STT makes it easy to breakdown in the transitional region compared with the straight region. Therefore, the transitional region is studied and the crucial parameter $\Delta {L}$ in the layout of transitional region is also optimized. The fabricated device experimentally demonstrated improved performance with low ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ of 78.3 $\text{m}\Omega \cdot $ cm2 and high breakdown voltage (BV) of 795 V, and the experimental ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ is 26.8% lower than that of the conventional triple RESURF LDMOS (CTR LDMOS) and 10% lower than that of the NTTR LDMOS based on ${L}_{d} = 67 \mu \text{m}$ , which can break the silicon limit of CTR and NTTR LDMOS and meet the demand of 700-V high-voltage integrated circuit applications.

Design of a 700 V DB-nLDMOS Based on Substrate Termination Technology

ADVANCED N-CHANNEL LDMOS WITH ULTRALOW SPECIFIC ON-RESISTANCE BY 0.18 mu m EPITAXIAL BCD TECHNOLOGY

The Investigation of Field Plate Design in 500 V High Voltage NLDMOS

Enhancement of Electrical Safe Operation Area of 60 V nLDMOS by Engineering of Reduced Surface Electrical Field in the Drift Region

Design and experimental verification of a novel high-reliability variation of lateral doping (VLD) termination

A Novel SiC LDMOS with Electric Field Optimization by Step Doping Technology

Ultra-Low On-Resistance SiC LDMOS With Separated-Protected Trench Gates and Trench RESURF Technology

A Novel Ultralow R ON,sp Triple RESURF LDMOS With Sandwich n-p-n Layer

A novel double-gate trench SOI LDMOS with double-dielectric material by TCAD Simulation Study

Study of Drain-Extended Nmos under Electrostatic Discharge Stress in 28 Nm and 40 Nm Cmos Process

Super Junction Lateral Double-Diffused MOSFET with Ultra-low Specific on-Resistance Completely Eliminating Substrate Assisted Depletion Effect

Design and optimization of a novel SOI LDMOS structure using PIN junction

A novel 25V DDD NMOS design in 500–700V ultra high voltage BCD process

Novel STI scheme and layout design to suppress the kink effect in LDMOS transistors

A High-k LDMOS Improved by Floating Field Plates for Enhanced Cost Performance and Robustness

Termination Design of 6.5kV SiC MOSFET with Epitaxial Current Spreading Layer

A Lateral Power P-Channel Trench MOSFET Improved by Variation Vertical Doping

Linearly Graded Doping Drift Region: a Novel Lateral Voltage-Sustaining Layer Used for Improvement of RESURF LDMOS Transistor Performances

A Low-Loss 1.2 kV SiC MOSFET with Improved UIS Performance

ESD-capability Study of High-voltage nLDMOSs with out the Drift Region DPW Effect

A 600V-Class Partial SOI LDMOS with Step-Doped Drift Region