Abstract:The thermophysical properties of dense ZrB2-20 vol% SiC ceramics (ZS) with and without doping of 5 vol % WC (ZSW) were characterized up to 1800 degrees C. Because of the in-situ formed WB with low thermal conductivity and the strong phonon scattering effect from (Zr,W)B-2 solid solution, the thermal conductivity of ZSW (36.2 W/(m K)) at room temperature is much lower than that of ZS (100.4 W/(m K)), however, their differences at 1800 degrees C is very limited (42.2 W/(m K) for ZSW and 47.4 W/(m . K) for ZS). The detailed calculation indicates that contributions from lattice vibrations on the thermal conductivity decreased to nearly zero at 1800 degrees C in both samples, therefore, electrical conductivity of ZS and ZSW dominates their thermal transport behavior at higher temperatures. Furthermore, amorphous phase with compositions of Ca-Al-Si-O was occasionally found at the triple junction of ZS, its softening and rewetting of the grain boundary at higher temperature were confirmed from the internal friction curve and microstructural characterization at different levels, which was thought to be responsible for the tremendous increase of Interfacial thermal resistance and continuous drop of thermal conductivity of ZS up to 1800 degrees C. On the contrary, benefiting from the clean boundary and tight triple junction in ZSW, its thermal conductivity can stabilize between 36 and 47 W/(m K) in a broad temperature range from 25 to 1800 degrees C. Based on the measurement above, the type of carriers and thermoelectric figure of merit (zT) in ZrB2-SiC based ceramics are also firstly reported. (C) 2017 Acta Materialia Inc. Published by Elsevier Ltd. All rights reserved.

Electrical Properties of ZrB2–SiC Ceramics with Potential for Heating Element Applications

Influence of Hot Pressing Temperature and SiC Content on the Microstructure and Mechanical Properties of ZrB2-SiC

Thermal and Electrical Transport in ZrB2-SiC-WC Ceramics Up to 1800 °C

Properties of ZrB2-SiC Ceramics by Pressureless Sintering

Investigation of Electrical Properties of Pressureless Sintered ZrB2-based Ceramics

Microstructure and Mechanical Properties of ZrB2-SiC Composites

Interface characteristics in ZrB2-based ceramics containing SiC and/or ZrC particles via hot-pressing sintering

Microstructure and High-Temperature Mechanical Properties of Zro2-Al2o3-Sic Ceramics

Microstructure and Properties of Hot Pressed Zr2(Al(Si))4C5/SiC Composites

Interface and defect characterization in hot-pressed ZrB2-SiC ceramics

Effect of the Addition of Short Carbon Fiber on Thermal Insulation Properties of ZrB2- SiC Hot-Pressed Ceramics

Mechanical Properties of ZrB<sub>2</sub>-Based Ceramics Reinforced by Nano-SiC Whiskers

Pressureless Sintering of Silicon Carbide Ceramics Containing Zirconium Diboride

Novel (Zr, Ti)B2-(Zr, Ti)C-SiC ceramics via reactive hot pressing

Microstructure and mechanical properties of hot pressed ZrC-SiC-ZrB 2 composites

Preparation and Mechanical Properties of ZrB2-based Ceramics Using MoSi2 As Sintering Aids

Synthesis, Mechanical and Physical Properties of Bulk Zr2Al4C5 Ceramic

Effect of ZrB2 powders on densification, microstructure, mechanical properties and thermal conductivity of ZrB2-SiC ceramics

Microstructure and properties of silicon carbide whisker reinforced zirconium diboride ultra-high temperature ceramics

Effects of SiC Platelet and ZrSi2 Additive on Sintering and Mechanical Properties of ZrB2-based Ceramics by Hot-Pressing

Mechanical properties and thermal shock behavior of hot-pressed ZrB2–SiC–AlN composites