Abstract:In order to study the mechanism of biomass tar formation and elimination in a two-stage downdraft gasifier, the nascent rice straw pyrolysis tar evolution properties under homogeneous/heterogeneous decomposition conditions have been investigated in a constructed lab-scale two-stage reactor by varying factors as temperature, concentration and reforming agents of CO(2)/H(2)O/O(2), and char bed heights. The nascent tar was produced in the first stage reactor and then decomposed in the second stage with different reforming agents or char beds. In the first stage, the results showed that nascent pyrolysis tar yields increased with increasing pyrolysis temperature, tar was mainly produced during 200-400 degrees C, and 400-500 degrees C would be a proper pyrolysis temperature range in commercial operation due to little effect on tar yields in higher temperature. In the second stage, it can be observed that nascent biomass tar was converted into polycyclic aromatic hydrocarbons (PAHs) (even soot), thermally stable one ring aromatics, and noncondensable gases in homogeneous conditions with increasing temperature. Different effects were obtained in varying tar species under different homogeneous reforming agents. However, benzene, toluene, styrene, phenol, and naphthalene are the most typical compounds, accounting for 50-75% in total tar concentration at 900 degrees C in all decomposition conditions. Char bed can selectively reduce PAH species remarkably and increase the toluene yields. As for the three reforming agents, steam showed the highest efficiency in tar elimination, while CO(2) and O(2) present will induce OH, H, and O radicals formation, which increases hydrocarbon conversion. The mechanism of tar destruction in a two-stage downdraft gasifier can be concluded as follows: nascent tar yields from the pyrolysis stage will be first reformed into PAHs, thermally stable one ring aromatics and noncondensable gases in the throat region, and then PAHs species are almost completely decomposed by the char bed, which are the main troublesome tar components in syngas, and finally the syngas with low tar was obtained.

Experimental Investigation of Tar Conversion under Inert and Partial Oxidation Conditions in a Continuous Reactor

Experimental and numerical investigation of tar destruction under partial oxidation environment

Experimental Investigation Of Tar Reduction Properties By Coupling Oxidative Pyrolysis And Partial Oxidation In A Continuous Reactor For Biomass Gasification

Experimental Study on Tar Destruction in a Two Stage Fixed-Bed Reactor

Experimental Investigation of the Synergy Effect of Partial Oxidation and Bio-Char on Biomass Tar Reduction

Experimental Investigation on Tar Formation and Destruction in A Lab-Scale Two-Stage Reactor

Investigation of Pyrolysis and Mild Oxidation Characteristics of Tar-Rich Coal via Thermogravimetric Experiments.

Regulation of Partial Oxidation in Biochar-Catalyzed Tar Reforming for Hydrogen Upgrading in Syngas: the Effect of Oxygen Concentration

ReaxFF MD and detailed reaction kinetic study on the thermal cracking and partial combustion of anisole: a biomass model tar compound

Heterogeneous Cracking Reaction of Tar over Biomass Char, Using Naphthalene As Model Biomass Tar

Experimental Study on Catalytic and Thermal Cracking of Tar from Biomass Pyrolysis

Experimental and Modeling Investigation on the Effect of Intrinsic and Extrinsic Oxygen on Biomass Tar Decomposition

Reaction mechanism for partial oxidation of biomass tar

Integrated Process of Coal Fast Pyrolysis in a Fluidized Bed Reactor with Reforming Reaction of Simulated Fuel Gas to Promote Light Tar Evolution

Influence of Catalytic Cracking of Tar on Gas Component

Experimental Study on Pyrolysis Tar Removal over Rice Straw Char and Inner Pore Structure Evolution of Char

Interaction mechanism in tar group components during the catalytic upgrading of gaseous tar

Nascent Biomass Tar Evolution Properties under Homogeneous/Heterogeneous Decomposition Conditions in a Two-Stage Reactor

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

EFFECT OF CHAR ON CATALYTIC CRACKING OF TAR FROM BIOMASS GASIFICATION GAS WITH TOLUENE AS A MODEL COMPOUND

Catalytic conversion characteristics of tar at different temperatures during circulating fluidized bed gasification