Abstract:Methanol to aromatics (MTA) following dual cycles concept unavoidably produced considerable amounts of olefinic intermediates and paraffinic by-products. Their formation and further conversion were vital to improving aromatics production. In this study, a two-stage fluid bed packed with fluid Zn/ZSM-5 catalyst in each stage was used to investigate the MTA reaction at 470 degrees C in the first stage and the secondary conversion of MTA primary products at temperatures from 270 degrees C to 550 degrees C in the second stage with time on stream. During the MTA reaction, the decrease of catalyst acidity was beneficial to controlling hydrogen transfer, thus blocking propane formation. During the secondary conversion of MTA products, at temperatures below 390 degrees C, the alkylation and hydrogen transfer reactions dominated and thus olefins were converted into more alkylbenzene as well as the undesired propane and butane. As the temperature increased from 430 degrees C to 550 degrees C, the aromatization of light hydrocarbon and the dealkylation of alkylbenzene were facilitated, producing more benzene and toluene but increasing methane and ethane yields. Meanwhile, the dehydrogenation and cracking of propane and butane were favored by high temperature and strong acidity so that the yields of ethene and propene increased. It was clarified that the characteristics of secondary conversion of MTA products varied and depended on reaction temperature and catalyst acidity. Based on these findings, the concept of regional functionalization of fluidized bed reactor was proposed for intensification of MTA process based on the reconfiguration of the temperature and acidity of catalyst stream during the fluidized bed reaction-regeneration cycle.

THERMODYNAMICS ON COUPLED CONVERSION OF BUTENE AND METHANOL TO ETHYLENE AND PROPYLENE

Enhanced Reaction Performances For Light Olefin Production From Butene Through Cofeeding Reaction With Methanol

Study on Complex Reaction Network and Kinetic Model of a Methanol to Propene Process

Direct Conversion of Methane to Propylene

Dynamic Simulation and Control schemes of hybrid membrane-distillation process on ethylene- ethane system

Simulation of Fluidized Bed Reactor for Methanol to Olefins(MTO)Process

Efficient Conversion of Methane to Aromatics in the Presence of Methanol at Low Temperature

Kinetic Perspective on Methanol to Propylene Process Via HZSM-5 Catalyst: Balancing Between Reaction and Diffusion

Thermodynamic Analysis of Propane Aromatization

Low-Temperature-Initiated Cracking of Hydrocarbons to Produce Olefins: Simulation and Comparison of Different Initiators

Techno-Economic Analysis of Methanol to Propylene Process

Enhancing Low-Temperature Methane Conversion on Zn/ZSM-5 in the Presence of Methanol by Regulating the Methanol-to-aromatics Reaction Pathway

Co-hydropyrolysis of Pine and HDPE over Bimetallic Catalysts: Efficient BTEX Production and Process Mechanism Analysis

DFT Studies on the Reaction Mechanism of Cross-Metathesis of Ethylene and 2-Butylene to Propylene over Heterogeneous Mo/HBeta Catalyst

Influence of temperature, residence time, and solvent/feedstock mass ratio on overall product distribution and oil products quality in ethanol liquefaction of 230 polypropylene impact copolymer

Light Olefin Production by Catalytic Co-Cracking of Fischer–Tropsch Distillate with Methanol and the Reaction Kinetics Investigation

Equilibrium analysis of methylbenzene intermediates for a methanol-to-olefins process

Thermodynamic and Kinetic Analysis of Catalytic Processes of Bioethanol Conversion for Hydrogen and Propylene Obtaining

Temperature-dependent Secondary Conversion of Primary Products from Methanol Aromatization in a Two-Stage Fluidized Bed

Catalytic conversion of C4 fraction for the production of light olefins and aromatics

Thermodynamic and Mechanistic Analyses of Direct CO 2 Methylation with Toluene to para -Xylene