Abstract:China owns the world's largest capacity of coal-fired power units. By the end of 2012, the capacity of installed national thermal power has been 819.68 million kilowatts. The latest standard requires that newly built power plants emit SO2 in no more than 100 mg/m(3) and the emission of old ones be lower than 200 mg/m(3) while in some key areas the emission should be controlled under 50 mg/m(3). So by the end of 2012, 90 % of the active coal-fired units have been equipped with flue gas desulfurization devices. Among the desulfurization methods adopted, limestone-gypsum wet flue gas desulphurization accounts for 92 %, causing the problem of fine droplets in the exhaust gas after defogger, which may even form "gypsum rain." At present, sampling methods are widely used at home and abroad, such as magnesium ion tracer method, modified magnesium ion tracer method and chemical analysis. In addition, some scholars use aerodynamic methods, such as ELPI, to measure the diameter distribution and concentration. The methods mentioned above all have their own demerits, such as the inability to on-line, continuous measurements and the need of prolonged measuring time. Thus, in this paper some potential optical on-line methods are presented, such as Fraunhofer diffraction pattern analysis and wavelength-multiplexed laser extinction. Also brought up are their measuring scope and merits. These methods have already been utilized to measure small liquid droplets and their demonstrations and evaluations are as well stated. Finally, a 3D imaging method based on digital holographic microscope is proposed for in-line measurement of size and concentration of slurry droplets. The feasibility of this method is demonstrated by preliminary experimental investigation.

Measurement of Temperature-Humidity Fields and Characterization of Liquid Phase Distribution in Gas-Liquid Regions

Humidity-temperature Measurement and Drying Characteristics in Multiphase Flow Region of Spray

Dynamic and Steady-State Characterization of the Liquid Spray Zone in an Externally Heated Gas–Solid Fluidized Bed

Hydrodynamics and Heat Transfer in a Fluidized Bed with Liquid Spray: Particle Color-Change Based Measurement and Modelling

Development of a new temperature measuring system for gas–liquid flow in spraying field

Detection of Liquid Atomization Status Using Acoustic Emission Method

Dynamic Characteristics of the Volatile Cloudy Zone in a Gas–solid Fluidized Bed with Hydrocarbon Liquid Spray

Development Study on Measuring Moisture of the Wet Steam Two Phase Flow

Device for temperature measurement in counter-current gas-liquid spraying field

Study on Gas–liquid Two-Phase Spraying Characteristics of Nozzles for the Humidification of Smoke

Development of a Volatility Hygroscopic Tandem Differential Mobility Analyzer (VH-TDMA) for the Measurement of Aerosol Thermal and Hygroscopic Properties

Measurement Method and Influencing Factors of Temperature and Humidity of Condensed Flue Gas Based on in Situ Flue Gas Heat Tracing

Research on Water Vapor Release and Adsorption Mechanism to Improve the Measurement of Dew Point Humidity Sensor

Development of an Innovative Mist-spray Optical Measuring Device

An Evaluation Method for Liquid Separation Structures in Gas-Droplet Two-Phase Flows

Experimental Study on the Characteristics of Water Vapor Generation from Gas-washing Bottle and Injector

Measurement of Moisture Content in a Fluidized Bed Dryer Using an Electrostatic Sensor Array

AN EXPERIMENTAL STUDY ON HUMIDIFYING PERFORMANCES IN COUNTERCURRENT HUMIDIFIER

Experimental Investigation of Spray Evaporation in Turbulent Flow in Countercurrent Humidifier

Experimental Research on Wetness Measurement With the Method of Gas-liquid Two-phase Flow Droplet Cluster Impingement

Measurement of Slurry Droplets in Coal-Fired Flue Gas after Wfgd