Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Impacts of poly-si gate pre-implanted dopant on the performance and HCI reliability of 65nm nmos device

Hot-carrier-induced On-Resistance Degradation of Step Gate Oxide NLDMOS

Analysis of 65 Nm Technology Grounded-Gate NMOS for On-Chip ESD Protection Applications

Influence of LDD Spacers and H+Transport on the Total-Ionizing-Dose Response of 65-Nm MOSFETs Irradiated to Ultrahigh Doses

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Total-Ionizing-Dose Effects and Low-Frequency Noise in 30-Nm Gate-Length Bulk and SOI FinFETs with SiO2/HfO2Gate Dielectrics

Statistical Analysis on the Effects of Heavy Ion Irradiation on 65 Nm Bulk Silicon MOS Devices

Total-Ionizing-Dose Response of Highly Scaled Gate-All-Around Si Nanowire CMOS Transistors

Performance Analysis of Ultra-thin-Body, Double-Gate pMOSFETs at 5 nm Technology Node

Comprehensive Stress Effect of Thin Coatings and Silicon-Carbon Lattice Mismatch on Nano-Scaled Transistors with Protruding Poly Gate

Effects of Nitrogen Implantation into Poly-Silicon Gate on 4.6nm Gate Oxide Properties

An Analytical Study of the Effect of Total Ionizing Dose on Body Current in 130-Nm PDSOI I/O Nmosfets

The Effect of Doping on the Digital Etching of Silicon-Selective Silicon–Germanium Using Nitric Acids

Pre-doping Effects on Ni Fully Silicided Metal Gate on SiO2 Dielectric

Influence of Mg doping level at the initial growth stage on the gate reliability of p-GaN gate HEMTs

A Multiscale Simulation on Aluminum Ion Implantation-Induced Defects in 4H-SiC MOSFETs

Impact of Nitrogen Incorporation on Low-Frequency Noise of Polycrystalline Silicon/TiN/HfO2/SiO2 Gate-Stack Metal–Oxide–Semiconductor Field-Effect Transistors

Highly-Doped Region Optimization for Reduced Hot-Carrier Effects in Dual-Gate Low Temperature Polysilicon TFTs

New Concerns on Heavy Ion Irradiation Induced Variation Degradation in Nanoscale CMOS Devices

Effects of SiON/III-nitride Interface Properties on Device Performances of GaN-based Power Field-Effect Transistors

Impact Of Gate Misalignment On The Performance Of Dopant-Segregated Schottky Barrier Mosfets